1994 BMW 525IT: Recalls, Problems & MPG
Here are the deets on the 1994 BMW 525IT: 2 recalls, 0 owner complaints and up to 20 mpg combined.
Recalls
2 vehicle recalls from the manufacturer. Repairs are free. Check your VIN to see if one is still open on your car.
Exterior lights Vehicle recall #96V111000 · 1996 · 180,000 vehicles
What's wrong: The brake light switch can fail allowing the switch to remain in the "brake lights off" position or in the "brake lights on" position.
Why it matters: If this happens, the brake lights either will not operate or will be continuously on, regardless of brake pedal position. Following drivers would not be able to determine whether the vehicle is stopping, increasing the potential for a vehicle accident.
The fix: Dealers will replace the existing brake light switch with a newly designed switch.
Speed control / throttle Vehicle recall #97V131000 · 1997 · 410,000 vehicles
What's wrong: The cruise control and throttle cables are attached to the same throttle valve actuating lever at the throttle housing. It is possible that the plastic bushing on either cable could break due to environmental influences coupled with vibration. If the bushing breaks, the outer cable housing can separate from the bushing. In this case, during application of the throttle pedal without cruise control being engaged, the…
Why it matters: This could cause the throttle valve to remain partially open. It his were to occur, the car might not decelerate as expected increasing the risk of a vehicle crash.
The fix: Dealers will install a spring steel clip on the outer tube of each cable in the area of the adjusting screw and plastic bushing. The clip is designed to prevent the outer tube from dislodging from the bushing.
Most-reported problems
No owner complaints have been filed with NHTSA for the 1994 BMW 525IT so far.
Engines & fuel economy (EPA)
| Engine | Transmission | Drive | City | Hwy | Comb. | Fuel |
|---|---|---|---|---|---|---|
| 2.5 L 6-cyl | Manual 5-spd | Rear-Wheel Drive | 17 | 26 | 20 | Premium |
| 2.5 L 6-cyl | Automatic 4-spd | Rear-Wheel Drive | 16 | 23 | 19 | Premium |
Want the full repair deets? Get the factory manual.
Recall and complaint data tells you what goes wrong. A service manual tells you how to fix it: torque specs, wiring diagrams, fluid capacities and step-by-step procedures for the 1994 BMW 525IT.
Closest thing to the factory manual for most years. Pay once, keep it.
Most $25–$78, one-timePro-shop repair procedures, wiring diagrams and TSBs for your exact car.
From $19.99/mo · $39.99/yrOEM procedures, specs and recall/TSB info, the same source many shops use.
From $19.99/mo · $59.99/yrStep-by-step photos written from a real teardown. Great for first-timers.
Books ~$30–$40 · AllAccess $34.99/moHeads up: we may earn a commission if you buy through these links, at no extra cost to you. Prices checked 2026-10 and can change. We never host or link to pirated manuals. Disclosure
FAQ
Does the 1994 BMW 525IT have any recalls?
Yes. NHTSA lists 2 vehicle recalls for the 1994 BMW 525IT. Recall repairs are free at any dealer, no matter how old the car is. Check your VIN at nhtsa.gov/recalls.
What gas mileage does the 1994 BMW 525IT get?
EPA ratings run up to 20 mpg combined (2.5 L, Manual 5-spd), across 2 engine and transmission combos.
Where can I get a 1994 BMW 525IT repair manual?
eManualOnline sells downloadable manuals, Mitchell 1 DIY and ALLDATAdiy sell online access to factory repair data, and Haynes sells printed guides and online access. Pick a download if you want to keep it, or a subscription for wiring diagrams and TSBs.