1991 Buick Regal: Recalls, Problems & MPG
Here are the deets on the 1991 Buick Regal: 6 recalls, 200 owner complaints and up to 20 mpg combined.
Recalls
6 vehicle recalls from the manufacturer, plus 1 equipment/tire recall that can apply. Repairs are free. Check your VIN to see if one is still open on your car.
Seat belts Vehicle recall #91V005000 · 1991 · 412,792 vehicles
What's wrong: Front shoulder safety belt webbing May separate at front belt upper guide loops on either side of the front seat.
Why it matters: Webbing separation could occur without prior warning andincrease the risk of injury to belted front outboard occupants in a high energycrash.
The fix: Install a controlled rotation bracket on driver and passenger side front seat belt guide loops.
Seat belts Vehicle recall #92V003000 · 1992 · 347,866 vehicles
What's wrong: The front door shoulder belt guide loops May be cracked and are not in compliance with fmvss 208.
Why it matters: The seat occupant faces increased risk of injury in theevent of a sudden stop or accident.
The fix: Install reinforcing plates on the cracked shoulder belt guides.
Fuel system Vehicle recall #93V145000 · 1993 · 11,432 vehicles
What's wrong: The fuel feed hose can pull out of the crimped coupling at the engine end of the hose assembly, causing fuel leakage.
Why it matters: If the coupling were to separate and an ignition sourceis present, an engine compartment fire could occur.
The fix: Install a new fuel feed hose.
Exterior lights Vehicle recall #95V152000 · 1995 · 83,247 vehicles
What's wrong: Incorrect clear front side marker bulbs were installed rather than amber bulbs. This does not conform to the requirements of fmvss no. 108, "lamps, reflective devices, and associated equipment."
Why it matters: Consequence of non-compliance: during illumination, the bulbs will show clear rather than amber and could momentarily confuse other drivers.
The fix: Dealers will replace the clear bulbs with the correct amber bulbs.
Body & structure Vehicle recall #97V058000 · 1997 · 676,535 vehicles
What's wrong: The rear cradle bolts pull through the retainers due to corrosion of the retainer. If both bolts pull through, the rear cradle would not longer be supported at these mounting locations and the steering intermediate shaft can separate from the steering gear.
Why it matters: If this were to occur while the vehicle was in motion, a vehicle crash could result.
The fix: Dealers will replace the rear cradle bolts and retainers.
Body & structure Vehicle recall #00V189000 · 2000 · 713,435 vehicles
What's wrong: A condition where one or both front engine cradle bolts can pull through the retainers due to corrosion of the retainers.
Why it matters: If both bolts pull through, the front of the cradle would no longer be supported at the mounting locations and the steering intermediate shaft could separate from the steering gear.
The fix: Dealers will replace the front and rear frame/cradle bolts and retainers.
1 aftermarket equipment / tire recall replacement parts sold to fit this car, not the car itself
Fuel system Equipment recall #06E043000 · 2006 · 88,303 vehicles
What's wrong: Certain replacement fuel filters, fram brand name p/n g3727, with date codes x52911 through x60801 sequentially or x600141 and a mexico country or origin marking on the fuel filter housing manufactured from October 18, 2005, through March 21, 2006, sold for use on the vehicles listed above and on certain school buses. (to see the school bus engine sizes, click on "document search" and then "bus applications"). The…
Why it matters: This condition May cause an inadequate seal at the connection, potentially leading to a fuel leak. In the presence of an ignition source, a fire could occur.
The fix: Honeywell will notify owners and replace the fuel filters free of charge. The recall began on October 18, 2006.
Most-reported problems
Owner complaints filed with NHTSA, by component. One complaint can list several components. 4 mention a fire, 8 injuries and 0 deaths were reported.
What owners describe
- Brakes (hydraulic) (114): the most common themes are brake failure / soft pedal (30), rust / corrosion (23).
- Body & structure (20): the most common themes are rust / corrosion (6), noise or vibration (5).
- Engine & cooling (15): the most common themes are fire / smoke (4), rust / corrosion (3), leaks (2).
- Seat belts (14): no single recurring theme in the descriptions.
The 1991 Buick Regal has 200 owner complaints, ranking #5 of 29 Regal model years for complaints (2.0× the average Regal year). Complaints peaked in 1995 (59 filed that year). The typical problem showed up when the car was about 6 years old, at a median of 94,209 miles. Neighboring years: 1990 (77 complaints, 8 recalls), 1992 (144 complaints, 2 recalls).
Engines & fuel economy (EPA)
| Engine | Transmission | Drive | City | Hwy | Comb. | Fuel |
|---|---|---|---|---|---|---|
| 3.1 L 6-cyl | Automatic 4-spd | Front-Wheel Drive | 17 | 28 | 20 | Regular |
| 3.8 L 6-cyl | Automatic 4-spd | Front-Wheel Drive | 17 | 26 | 20 | Regular |
Want the full repair deets? Get the factory manual.
Recall and complaint data tells you what goes wrong. A service manual tells you how to fix it: torque specs, wiring diagrams, fluid capacities and step-by-step procedures for the 1991 Buick Regal.
Closest thing to the factory manual for most years. Pay once, keep it.
Most $25–$78, one-timePro-shop repair procedures, wiring diagrams and TSBs for your exact car.
From $19.99/mo · $39.99/yrOEM procedures, specs and recall/TSB info, the same source many shops use.
From $19.99/mo · $59.99/yrStep-by-step photos written from a real teardown. Great for first-timers.
Books ~$30–$40 · AllAccess $34.99/moHeads up: we may earn a commission if you buy through these links, at no extra cost to you. Prices checked 2026-10 and can change. We never host or link to pirated manuals. Disclosure
FAQ
Does the 1991 Buick Regal have any recalls?
Yes. NHTSA lists 6 vehicle recalls for the 1991 Buick Regal, plus 1 equipment or tire recalls that can apply. Recall repairs are free at any dealer, no matter how old the car is. Check your VIN at nhtsa.gov/recalls.
What are the most common 1991 Buick Regal problems?
Owners have filed 200 complaints with NHTSA. The most-reported areas are brakes (hydraulic) (114), body & structure (20), engine & cooling (15).
What gas mileage does the 1991 Buick Regal get?
EPA ratings run up to 20 mpg combined (3.1 L, Automatic 4-spd), across 2 engine and transmission combos.
Where can I get a 1991 Buick Regal repair manual?
eManualOnline sells downloadable manuals, Mitchell 1 DIY and ALLDATAdiy sell online access to factory repair data, and Haynes sells printed guides and online access. Pick a download if you want to keep it, or a subscription for wiring diagrams and TSBs.