2021 Ford E-350: Recalls, Problems & MPG
Here are the deets on the 2021 Ford E-350: 6 recalls, 22 owner complaints.
Recalls
6 vehicle recalls from the manufacturer. Repairs are free. Check your VIN to see if one is still open on your car.
Transmission & drivetrain, Transmission & drivetrain Vehicle recall #20V099000 · 2020 · 319 vehicles
What's wrong: The rear axle differential fluid May be below the minimum level, possibly resulting in a failure of the rear axle assembly and driveshaft separation.
Why it matters: If the driveshaft separates, there May be a loss of drive, increasing the risk of crash. Additionally, if the parking brake is not applied, unintended vehicle movement can occur and increase the risk of injury or crash.
The fix: Ford will notify owners, and dealers will inspect the rear axle differential fluid level and adjust it, or replace the rear axle as necessary, free of charge. The recall began March 19, 2020.
Stability control, Electrical Vehicle recall #20V175000 · 2020 · 2,871 vehicles
What's wrong: A wire harness in the rear of the vehicle May contact the vehicle frame, resulting in damage to the circuits that support the fuel pump and the anti-lock braking system (ABS).
Why it matters: Damage to the fuel pump circuit in the wiring harness could result in an unexpected engine stall. Damage to the ABS wiring can lead to reduction of ABS functionality and a loss of roll stability control (rsc) functionality. These scenarios increase the risk of a crash.
The fix: Ford will notify owners, and dealers will inspect the wire harness for damage. If no damage is found, dealers will apply anti-abrasion tape over the area and ensure clearance to surrounding components. If damage is found, dealers will splice in new wire and apply anti-abrasion tape over the area…
Engine Vehicle recall #20V795000 · 2020 · 29,344 vehicles
What's wrong: The underside of the engine cover May have mispositioned insulation, allowing the cover to get excessively hot.
Why it matters: Direct and continuous contact with certain areas of engine cover surface in the passenger compartment May increase the risk of injury or burns to the skin of the driver or front seat passenger.
The fix: Ford will notify owners, and dealers will inspect the engine cover for gaps between the rubber seal and the insulation. If gaps are present, the dealer will install engine cover insulation patches in the right hand and left hand inner lower corners of the engine cover. The dealer will also update…
Brakes (hydraulic), Steering Vehicle recall #22V089000 · 2022 · 44,219 vehicles
What's wrong: An inadequate connection between the power steering pressure line and the brake hydroboost unit May result in a sudden loss of power steering fluid.
Why it matters: A sudden loss of power steering fluid can result in a loss of power steering and power brake assist, increasing the risk of a crash.
The fix: Dealers will inspect the connection between the power steering lines and the hydroboost unit, and replace the power steering lines, as necessary, free of charge. Owner notification letters were mailed on March 18, 2022.
Brakes (hydraulic), Steering Vehicle recall #24V097000 · 2024 · 16,543 vehicles
What's wrong: An inadequate connection between the power steering pressure line and the brake hydroboost unit May result in a sudden loss of power steering fluid.
Why it matters: A sudden loss of power steering fluid can result in a loss of power steering and power brake assist, increasing the risk of a crash.
The fix: Dealers will replace the power steering pressure line and the hydroboost jumper line, free of charge. Vehicles in this recall were previously recalled under 22v-089 and owners will need to have the new remedy completed even if their vehicle was remedied under the prior recall. Owner notification…
Engine Vehicle recall #25V793000 · 2025 · 7,046 vehicles
What's wrong: The engine cover May become excessively hot.
Why it matters: Direct contact with certain areas of engine cover surface in the passenger compartment May increase the risk of injury or burns to the skin of the driver or front seat passenger.
The fix: Dealers will update the powertrain calibration for heat management under elevated idle conditions, free of charge. Owner notification letters were mailed January 7, 2026.
Most-reported problems
Owner complaints filed with NHTSA, by component. One complaint can list several components. 0 mention a fire, 0 injuries and 0 deaths were reported.
What owners describe
- Engine (11): the most common themes are stalls / loses power (2).
- Steering (7): the most common themes are steering problems (6), leaks (4), warning light on (2).
- Brakes (hydraulic) (5): the most common themes are leaks (3), warning light on (2).
- Other / unknown (2): no single recurring theme in the descriptions.
The 2021 Ford E-350 has 22 owner complaints, ranking #16 of 35 E-350 model years for complaints (about average; the typical year has 29). Complaints peaked in 2024 (7 filed that year). The typical problem showed up when the car was about 3 years old, at a median of 12,233 miles. Neighboring years: 2020 (2 complaints, 0 recalls), 2022 (14 complaints, 3 recalls).
Want the full repair deets? Get the factory manual.
Recall and complaint data tells you what goes wrong. A service manual tells you how to fix it: torque specs, wiring diagrams, fluid capacities and step-by-step procedures for the 2021 Ford E-350.
Closest thing to the factory manual for most years. Pay once, keep it.
Most $25–$78, one-timePro-shop repair procedures, wiring diagrams and TSBs for your exact car.
From $19.99/mo · $39.99/yrOEM procedures, specs and recall/TSB info, the same source many shops use.
From $19.99/mo · $59.99/yrStep-by-step photos written from a real teardown. Great for first-timers.
Books ~$30–$40 · AllAccess $34.99/moHeads up: we may earn a commission if you buy through these links, at no extra cost to you. Prices checked 2026-10 and can change. We never host or link to pirated manuals. Disclosure
FAQ
Does the 2021 Ford E-350 have any recalls?
Yes. NHTSA lists 6 vehicle recalls for the 2021 Ford E-350. Recall repairs are free at any dealer, no matter how old the car is. Check your VIN at nhtsa.gov/recalls.
What are the most common 2021 Ford E-350 problems?
Owners have filed 22 complaints with NHTSA. The most-reported areas are engine (11), steering (7), brakes (hydraulic) (5).
Where can I get a 2021 Ford E-350 repair manual?
eManualOnline sells downloadable manuals, Mitchell 1 DIY and ALLDATAdiy sell online access to factory repair data, and Haynes sells printed guides and online access. Pick a download if you want to keep it, or a subscription for wiring diagrams and TSBs.