1991 Honda Accord: Recalls, Problems & MPG
Here are the deets on the 1991 Honda Accord: 3 recalls, 212 owner complaints and up to 23 mpg combined.
Recalls
3 vehicle recalls from the manufacturer, plus 10 equipment/tire recalls that can apply. Repairs are free. Check your VIN to see if one is still open on your car.
Interior lights Vehicle recall #91V195000 · 1991 · 19,688 vehicles
What's wrong: A washer in the cargo area light May not be properly attached, and May have fallen in the cargo light during assembly. If this occurred, and the three position light switch is in the middle position, and the tailgate is open, the washer can cause a short circuit in the light.
Why it matters: The light short circuit could cause the switch tooverheat and result in a cargo compartment fire.
The fix: Remove the washers behind the cargo area light and replace any damaged light assemblies.
Seat belts Vehicle recall #93V056000 · 1993 · 45,958 vehicles
What's wrong: The rear outside seating position safety belts May lock up at angles other than those required by fmvss 209, "seat belt assemblies". This does not conform to the motor vehicle safety standard.
Why it matters: Non-conforming safety belts cause an increased risk of injury in the event of a sudden stop or accident.
The fix: Replace the sensor in the rear seat belt retractor.
Seat belts Vehicle recall #95V103001 · 1995 · 3,700,000 vehicles
What's wrong: The front safety belt buckle release buttons can break. These red plastic release buttons are marked "press." if a button breaks, pieces can fall into the buckle assembly causing the buckle to operate improperly.
Why it matters: The safety belts would not provide adequate protection to an occupant in a vehicle crash.
The fix: Owners should promptly check the condition and operation of both front safety belt buckles. Carefully inspect the red release button for any breaks or cracks. Check that both buckles are operating properly by inserting each latch plate into its buckle, tug on the belt to make sure the latch is…
10 aftermarket equipment / tire recalls replacement parts sold to fit this car, not the car itself
Exterior lights Equipment recall #06E023000 · 2006 · 292,000 vehicles
What's wrong: Certain anzo combination headlamp assemblies sold as replacement lamps for use on certain passenger vehicles. Some combination lamps are not equipped with amber side reflectors which fail to conform to Federal Motor Vehicle Safety Standard no. 108, "lamps, reflective devices, and associated equipment."
Why it matters: Without the amber reflectors, the vehicle will be poorly illuminated, possibly resulting in a vehicle crash.
The fix: Anzo will notify owners and replace the headlamps free of charge. The recall began May 9, 2006.
Exterior lights Equipment recall #06E025000 · 2006 · 1,450 vehicles
What's wrong: Certain poli-auto combination headlamp assemblies, p/nos. 11-728, 11-728d, 11-710, 11-419, 11-713, 11-703, 11-704, 11-708p, 11-735, 11-725, 11-726, 11-716 (p&c), 11-721-1, 11-733, 11-729, 11-730, and 11-732, sold as replacement lamps for use on certain passenger vehicles. Some combination lamps that are not equipped with amber side reflectors fail to conform to Federal Motor Vehicle Safety Standard no. 108, "lamps,…
Why it matters: Without the amber reflectors, the vehicle will be poorly illuminated, possibly resulting in a vehicle crash without warning.
The fix: Poli-auto will notify owners and offer to repurchase the headlamps at its original purchase price. The recall is expected to begin during April 2006.
Exterior lights Equipment recall #06E026000 · 2006 · 61,944 vehicles
What's wrong: Certain pro-a motors corner lamps, turn signals, and headlights sold as replacement lamps for use on certain passenger vehicles listed above. Some combination lamps that are not equipped with amber side reflectors fail to conform to Federal Motor Vehicle Safety Standard no. 108, lamps, reflective devices, and associated equipment.
Why it matters: Without the amber reflectors, the vehicle will be poorly illuminated, possibly resulting in a vehicle crash without warning.
The fix: Pro-a motors will notify owners and offer to repurchase the lamps. The recall began on April 3, 2006.
Exterior lights Equipment recall #06E032000 · 2006 · 845 vehicles
What's wrong: Certain Eagle eyes and sonar headlights and corner lights sold as aftermarket for use on 1988-2005 Honda civic, 1990-2005 Honda accord, and 1990-2001 Acura integra passenger vehicles listed above. Headlights and corner lights that are not equipped with amber side reflectors fail to conform to Federal Motor Vehicle Safety Standard no. 108, lamps, reflective devices, and associated equipment.
Why it matters: Without the amber reflectors, the vehicle will be poorly illuminated, possibly resulting in a vehicle crash without warning.
The fix: Tom motorsport will notify owners and offer reimbursement for the purchase of noncompliant lights. The recall began April 17, 2006.
Exterior lights Equipment recall #06E049000 · 2006 · 27,176 vehicles
What's wrong: Certain ck motorsports combination headlights, clear corner, bumper, and side marker lights sold as replacement lamps for use on the passenger vehicles listed above. Some combination lamps that are not equipped with amber side reflectors fail to conform to Federal Motor Vehicle Safety Standard no. 108, lamps, reflective devices, and associated equipment.
Why it matters: Without the amber reflectors, the vehicle will be poorly illuminated, possibly resulting in a vehicle crash without warning.
The fix: Ck motorsport will notify owners and replace the noncompliant lamps free of charge. The recall began on July 1, 2006.
Exterior lights Equipment recall #06E060000 · 2006 · 87,745 vehicles
What's wrong: Certain aai motorsports combination lamps sold as replacement lamps for use on the above list passenger vehicles. Combination lamps not equipped with amber side reflectors fail to conform with the requirements of Federal Motor Vehicle Safety Standard no. 108, "lamps, reflective devices, and associated equipment."
Why it matters: Lack of amber side reflectors in the lamps will decrease lighting visibility to other drivers and May possibly result in a vehicle crash
The fix: Aai motorsports will notify owners and replace the lamps free of charge. The recall began on August 1, 2006.
Exterior lights Equipment recall #06E064000 · 2006 · 4,029 vehicles
What's wrong: Certain tradesonic combination lamps sold as replacement lamps for use on the above listed passenger vehicles. Combination lamps not equipped with amber side reflectors fail to conform with the requirements of Federal Motor Vehicle Safety Standard no. 108, lamps, reflective devices, and associated equipment.
Why it matters: Lack of amber side reflectors in the lamps will decrease lighting visibility to other drivers and May possibly result in a vehicle crash.
The fix: Tradesonic will notify owners and replace the lamps free of charge. The recall is expected to begin during July 2006.
Exterior lights Equipment recall #08E050000 · 2008 · 1,921 vehicles
What's wrong: These headlamps are missing the amber side reflex reflector which fails to conform with the requirements of Federal Motor Vehicle Safety Standard no. 108, "lamps, reflective devices, and associated equipment."
Why it matters: Without the amber side reflex reflectors, the lighting visibility May be affected, possibly resulting in a vehicle crash.
The fix: K2 motor will notify owners and offer a full refund. The recall began on decemeber 17, 2008.
Exterior lights Equipment recall #09E012000 · 2009 · 16,270 vehicles
What's wrong: These headlamps fail to conform to the requirements of Federal Motor Vehicle Safety Standard no. 108, "lamps, reflective devices, and associated equipment." these lamps do not contain the required amber side reflectors.
Why it matters: Decreased lighting visibility May result in a vehicle crash.
The fix: Sabersport will notify owners and offer a full refund for the noncompliant combination lamps. The safety recall began on May 11, 2009.
Exterior lights Equipment recall #09E025000 · 2009 · 42,540 vehicles
What's wrong: Dope, Inc. is recalling 42,540 combination corner and bumper lamp assemblies of various part numbers sold for use as aftermarket equipment for various passenger vehicles. These headlamps fail to conform to the requirements of Federal Motor Vehicle Safety Standard no. 108, "lamps, reflective devices, and associated equipment." these lamps do not contain the required amber side reflectors.
Why it matters: Decreased lighting visibility May result in a vehicle crash.
The fix: Dope, Inc. will notify owners and offer a full refund for the noncompliant combination lamps. The safety recall began on July 28, 2009.
Most-reported problems
Owner complaints filed with NHTSA, by component. One complaint can list several components. 6 mention a fire, 19 injuries and 0 deaths were reported.
What owners describe
- Seat belts (58): the most common themes are warning light on (7), electrical failure (4).
- Body & structure (32): the most common themes are door / lock issues (21), rust / corrosion (4).
- Latches & locks (24): the most common themes are door / lock issues (23).
- Transmission & drivetrain (18): the most common themes are hard / delayed shifting (8).
The 1991 Honda Accord has 212 owner complaints, ranking #30 of 37 Accord model years for complaints (well below the 653 average). Complaints peaked in 1996 (32 filed that year). The typical problem showed up when the car was about 9 years old, at a median of 166,219 miles. Neighboring years: 1990 (192 complaints, 2 recalls), 1992 (206 complaints, 2 recalls).
Engines & fuel economy (EPA)
| Engine | Transmission | Drive | City | Hwy | Comb. | Fuel |
|---|---|---|---|---|---|---|
| 2.2 L 4-cyl | Manual 5-spd | Front-Wheel Drive | 21 | 27 | 23 | Regular |
| 2.2 L 4-cyl | Automatic 4-spd | Front-Wheel Drive | 19 | 26 | 22 | Regular |
Want the full repair deets? Get the factory manual.
Recall and complaint data tells you what goes wrong. A service manual tells you how to fix it: torque specs, wiring diagrams, fluid capacities and step-by-step procedures for the 1991 Honda Accord.
Closest thing to the factory manual for most years. Pay once, keep it.
Most $25–$78, one-timePro-shop repair procedures, wiring diagrams and TSBs for your exact car.
From $19.99/mo · $39.99/yrOEM procedures, specs and recall/TSB info, the same source many shops use.
From $19.99/mo · $59.99/yrStep-by-step photos written from a real teardown. Great for first-timers.
Books ~$30–$40 · AllAccess $34.99/moHeads up: we may earn a commission if you buy through these links, at no extra cost to you. Prices checked 2026-10 and can change. We never host or link to pirated manuals. Disclosure
FAQ
Does the 1991 Honda Accord have any recalls?
Yes. NHTSA lists 3 vehicle recalls for the 1991 Honda Accord, plus 10 equipment or tire recalls that can apply. Recall repairs are free at any dealer, no matter how old the car is. Check your VIN at nhtsa.gov/recalls.
What are the most common 1991 Honda Accord problems?
Owners have filed 212 complaints with NHTSA. The most-reported areas are seat belts (58), body & structure (32), latches & locks (24).
What gas mileage does the 1991 Honda Accord get?
EPA ratings run up to 23 mpg combined (2.2 L, Manual 5-spd), across 2 engine and transmission combos.
Where can I get a 1991 Honda Accord repair manual?
eManualOnline sells downloadable manuals, Mitchell 1 DIY and ALLDATAdiy sell online access to factory repair data, and Haynes sells printed guides and online access. Pick a download if you want to keep it, or a subscription for wiring diagrams and TSBs.