2005 Honda Odyssey: Recalls, Problems & MPG
Here are the deets on the 2005 Honda Odyssey: 8 recalls, 830 owner complaints and up to 20 mpg combined.
.jpg){kind=link}
Recalls
8 vehicle recalls from the manufacturer, plus 1 equipment/tire recall that can apply. Repairs are free. Check your VIN to see if one is still open on your car.
Brakes (air) Vehicle recall #04V536000 · 2004 · 2,247 vehicles
What's wrong: On certain minivans, the anti-lock brake system (ABS) uses a sensor on each wheel to detect wheel speed. Some sensors on the rear wheels were installed incorrectly, which means the sensor May report the wrong wheel speed to the ABS control unit.
Why it matters: The driver could experience a loss of brake force and a crash could occur.
The fix: Dealers will inspect the rear wheel speed sensors. If an incorrect gap is detected, the sensor will be removed and the knuckle checked for cross threading damage. If damage is found, the knuckle will be replaced. If no damage is found, the sensor will be reinstalled correctly. The recall began on…
Steering Vehicle recall #05V039000 · 2005 · 203 vehicles
What's wrong: On certain minivans and sport utility vehicles, the steering column May be incorrectly assembled, which could result in a loss of steering control.
Why it matters: Loss of steering control can cause a vehicle crash without prior notice.
The fix: Owners were notified by telephone on January 25, 2005, and arrangements were made to have their vehicles towed to their dealers and have the repairs performed. The recall began on January 25, 2005.
Electrical Vehicle recall #05V132000 · 2005 · 1,923 vehicles
What's wrong: On certain passenger vehicles, a loose terminal in the main fuse box May cause the fuel pump to lose power. If the fuel pump becomes inoperative, the engine May not start.
Why it matters: If the fuel pump loses power while driving the engine could stall without warning which could result in a crash.
The fix: Dealers will replace the entire fuse box free of charge. The recall began on April 13, 2005.
Airbags Vehicle recall #05V344000 · 2005 · 85,154 vehicles
What's wrong: The frontal air bag system has two external impact sensors. On certain MINI vans,some sensors were insufficiently sealed during manufacturing. If water enters a sensor, corrosion can occur. Corroded sensors could short circuit internally. If sensors fail, the SRS warning lamp on the instrument panel will turn on and remain illuminated.
Why it matters: Front impact sensor failure could cause a delay in, or loss of, frontal air bag deployment, which can increase the risk of injury in a frontal crash.
The fix: Dealers will replace the front impact sensors. The recall began on August 30, 2005.
Fuel system Vehicle recall #07V097000 · 2007 · 166,561 vehicles
What's wrong: On certain vehicles, a coil wire inside the fuel pump relay May break, causing the fuel pump to lose power. If the fuel pump becomes inoperative, the engine May not start.
Why it matters: If the fuel pump loses power while driving, the engine could stall without warning, and a crash could occur.
The fix: Dealers will inspect and replace the fuel pump relay free of charge. The recall began on April 2, 2007.
Body & structure, Body & structure Vehicle recall #10V055000 · 2010 · 21,776 vehicles
What's wrong: The power liftgate gas struts May deteriorate unexpectedly early. Struts that have worn out prematurely May fail to hold the power liftgate in the fully open position, causing the power liftgate to close unexpectedly.
Why it matters: Injury May result from a power liftgate closing unexpectedly when a person is within the closing path of the liftgate.
The fix: Dealers will inspect the gas liftgate struts and replace if within the recall population. This service will be performed free of charge. The campaign began on March 26, 2010.
Brakes (hydraulic) Vehicle recall #10V504000 · 2010 · 471,820 vehicles
What's wrong: Brake fluid containing polymers is used that acts as a lubricant for certain brake system components. If replacement brake fluid is used that does not contain such polymers, or that contains only small amounts, a part of the rubber seal located at the rear of the brake master cylinder May become dry, and the seal May curl during movement of the piston. If this occurs, a small amount of brake fluid could slowly leak…
Why it matters: A leak of brake fluid could lead to a change in brake pedal feel and overtime a degradation in braking performance increasing the risk of a crash.
The fix: Dealers will replace the brake master cylinder seal free of charge. The recall is expected to begin during December 2010.
Fuel system Vehicle recall #14V112000 · 2014 · 886,815 vehicles
What's wrong: American Honda motor Co., Inc. (Honda) is recalling certain 2005-2010 Honda odyssey vehicles manufactured June 23, 2004, through September 4, 2010. In the affected vehicles, the fuel pump strainer cover May deteriorate allowing fuel to leak out.
Why it matters: A fuel leak increases the risk of a fire.
The fix: Parts to permanently repair the affected vehicles are not currently available. Honda will notify owners with an interim letter during May 2014. A second notice was mailed to owners October 6, 2014 when the remedy became available. Any vehicles that are currently leaking from the fuel pump cover…
1 aftermarket equipment / tire recall replacement parts sold to fit this car, not the car itself
Fuel system Equipment recall #14E049000 · 2014 · 280 vehicles
What's wrong: The affected fuel pump May send an incorrect fuel reading to the fuel gauge possibly causing the vehicle to run out of fuel. The fuel gauge will always read 3/4 full to full regardless of the actual level.
Why it matters: A vehicle that runs out of fuel and stalls has an increased risk of a crash.
The fix: Delphi has begun notifying dealers and distributors, and will replace the fuel pump modules, free of charge.
Most-reported problems
Owner complaints filed with NHTSA, by component. One complaint can list several components. 9 mention a fire, 32 injuries and 0 deaths were reported.
What owners describe
- Body & structure (138): the most common themes are door / lock issues (84), noise or vibration (21).
- Transmission & drivetrain (106): the most common themes are noise or vibration (30), hard / delayed shifting (29), stalls / loses power (8).
- Steering (99): the most common themes are steering problems (92), noise or vibration (32).
- Airbags (90): the most common themes are warning light on (34).
The 2005 Honda Odyssey has 830 owner complaints, ranking #5 of 34 Odyssey model years for complaints (2.2× the average Odyssey year). Complaints peaked in 2010 (94 filed that year). The typical problem showed up when the car was about 5 years old, at a median of 74,210 miles. Neighboring years: 2004 (585 complaints, 13 recalls), 2006 (703 complaints, 3 recalls).
Engines & fuel economy (EPA)
| Engine | Transmission | Drive | City | Hwy | Comb. | Fuel |
|---|---|---|---|---|---|---|
| 3.5 L 6-cyl | Automatic 5-spd | Front-Wheel Drive | 17 | 26 | 20 | Regular |
| 3.5 L 6-cyl | Automatic 5-spd | Front-Wheel Drive | 17 | 23 | 19 | Regular |
Want the full repair deets? Get the factory manual.
Recall and complaint data tells you what goes wrong. A service manual tells you how to fix it: torque specs, wiring diagrams, fluid capacities and step-by-step procedures for the 2005 Honda Odyssey.
Closest thing to the factory manual for most years. Pay once, keep it.
Most $25–$78, one-timePro-shop repair procedures, wiring diagrams and TSBs for your exact car.
From $19.99/mo · $39.99/yrOEM procedures, specs and recall/TSB info, the same source many shops use.
From $19.99/mo · $59.99/yrStep-by-step photos written from a real teardown. Great for first-timers.
Books ~$30–$40 · AllAccess $34.99/moHeads up: we may earn a commission if you buy through these links, at no extra cost to you. Prices checked 2026-10 and can change. We never host or link to pirated manuals. Disclosure
FAQ
Does the 2005 Honda Odyssey have any recalls?
Yes. NHTSA lists 8 vehicle recalls for the 2005 Honda Odyssey, plus 1 equipment or tire recalls that can apply. Recall repairs are free at any dealer, no matter how old the car is. Check your VIN at nhtsa.gov/recalls.
What are the most common 2005 Honda Odyssey problems?
Owners have filed 830 complaints with NHTSA. The most-reported areas are body & structure (138), transmission & drivetrain (106), steering (99).
What gas mileage does the 2005 Honda Odyssey get?
EPA ratings run up to 20 mpg combined (3.5 L, Automatic 5-spd), across 2 engine and transmission combos.
Where can I get a 2005 Honda Odyssey repair manual?
eManualOnline sells downloadable manuals, Mitchell 1 DIY and ALLDATAdiy sell online access to factory repair data, and Haynes sells printed guides and online access. Pick a download if you want to keep it, or a subscription for wiring diagrams and TSBs.