2005 Pontiac G6: Recalls, Problems & MPG
Here are the deets on the 2005 Pontiac G6: 5 recalls, 679 owner complaints and up to 23 mpg combined.
Recalls
5 vehicle recalls from the manufacturer, plus 1 equipment/tire recall that can apply. Repairs are free. Check your VIN to see if one is still open on your car.
Equipment Vehicle recall #05V098000 · 2005 · 35,777 vehicles
What's wrong: Certain passenger vehicles fail to conform to the requirements of Federal Motor Vehicle Safety Standard no. 225, 'child restraint anchorage systems.' the child restraint lower anchors in the center rear seating position are located approximately 90mm behind the corresponding z-point of the child restraint fixture (crf). The owner's manual states that anchors are at the outboard seating positions only.
Why it matters: Without additional and corrected owner's manual information, an owner May encounter difficulty in installing child restraints with rigid attachments in the center position.
The fix: Owners will be mailed an owner's manual supplement. The recall ibegan on March 20, 2005.
Exterior lights Vehicle recall #09V036000 · 2009 · 8,012 vehicles
What's wrong: The brake lamps May not operate properly because of corrosion in a wiring connector. Corrosion in the connector could cause the brake lamps to illuminate when the brake pedal has not been depressed, or the lamps May not illuminate when the brake pedal is depressed. In addition, the cruise control May not engage, and greater brake pedal force May be required to shift the vehicle out of park.
Why it matters: Brake lamps that are not operating properly May not warn a driver in a following vehicle of the braking status and could lead to a crash without prior warning.
The fix: Dealers will apply a dielectric lubricant to the connector to prevent corrosion. This service will be performed for you free of charge. The recall began on February 17, 2009.
Steering Vehicle recall #14V153000 · 2014 · 1,373,177 vehicles
What's wrong: In the affected vehicles, there May be a sudden loss of electric power steering (eps) assist that could occur at any time while driving.
Why it matters: If power steering assist is lost, greater driver effort would be required to steer the vehicle at low speeds, increasing the risk of a crash.
The fix: Gm will notify owners, and dealers will perform one of four bulletins. Parts are not currently available. Gm expects to send an interim notification around May 28, 2014. When parts are available, owners will be mailed a second letter to come in to have the applicable bulletin applied. Bulletin…
Transmission & drivetrain, Transmission & drivetrain Vehicle recall #14V224000 · 2014 · 1,131,113 vehicles
What's wrong: On May 22, 2014, gm increased the recall to include an additional 1,074,899 model year 2004-2008 Chevrolet malibu vehicles manufactured from May 16, 2003, through October 5, 2007, model year 2004-2007 malibu maxx vehicles manufactured from June 25, 2003, through April 5, 2007, and model year 2005-2008 Pontiac g6 vehicles manufactured from May 26, 2004, through September 28, 2007, and equipped with 4-speed…
Why it matters: If the transmission shift cable fractures while the vehicle is being driven, the transmission gear selection May not match the indicated gear and the vehicle May move in an unintended or unexpected direction, increasing the risk of a crash. Furthermore, when the driver goes to stop and park the…
The fix: Gm will notify owners, and gm dealers will replace the shift cable assembly and mounting bracket, free of charge. The manufacturer has not yet provided a notification schedule.
Stability control, Speed control / throttle Vehicle recall #14V252000 · 2014 · 2,440,524 vehicles
What's wrong: In the affected vehicles, increased resistance in the body control module (bcm) connection May result in voltage fluctuations in the brake apply sensor (bas) circuit. These fluctuations can cause one or more of these conditions: the brake lights to illuminate without the brake pedal being pushed; the brake lights to not illuminate when the pedal is pushed; difficulty disengaging the cruise control; moving the gear…
Why it matters: Any of the above failure conditions increases the risk of a crash.
The fix: Gm will notify owners, and dealers will attach the wiring harness to the bcm with a spacer, apply dielectric lubricant to both the bcm and harness connector and the bas and harness connector, and will relearn the brake pedal home position, free of charge. The manufacturer distributed an interim…
1 aftermarket equipment / tire recall replacement parts sold to fit this car, not the car itself
Steering Equipment recall #14E044000 · 2014 · 7,304 vehicles
What's wrong: Dorman products, Inc. (dorman) is recalling certain replacement intermediate steering shafts sold under the dorman, oe solutions, and solutions brand names, part numbers 425-167, 2425167, and 7-3074, for installation on 2004-2012 Chevrolet malibu, 2005-2010 Pontiac g6, and 2007-2009 Saturn aura vehicles. The affected steering shafts May have a yoke that inadequately supports the u-joint bearing resulting in a…
Why it matters: A joint bearing that fails prematurely May cause separation of the u-joint resulting in a complete loss of steering control, increasing the risk of a crash.
The fix: Dorman will notify owners, and dealers will refund the purchase price or replace the steering shafts, free of charge. The recall began in September 2014.
Most-reported problems
Owner complaints filed with NHTSA, by component. One complaint can list several components. 4 mention a fire, 17 injuries and 0 deaths were reported.
What owners describe
- Steering (459): the most common themes are steering problems (443), warning light on (83).
- Electrical (86): the most common themes are electrical failure (27), door / lock issues (20).
- Exterior lights (62): the most common themes are warning light on (21), electrical failure (11).
- Transmission & drivetrain (48): the most common themes are hard / delayed shifting (22), warning light on (7).
The 2005 Pontiac G6 has 679 owner complaints, ranking #5 of 9 G6 model years for complaints (about average; the typical year has 654). Complaints peaked in 2010 (91 filed that year). The typical problem showed up when the car was about 5 years old, at a median of 80,371 miles. Neighboring years: 2004 (2 complaints, 0 recalls), 2006 (1910 complaints, 6 recalls).
Engines & fuel economy (EPA)
| Engine | Transmission | Drive | City | Hwy | Comb. | Fuel |
|---|---|---|---|---|---|---|
| 3.5 L 6-cyl | Automatic 4-spd | Front-Wheel Drive | 20 | 29 | 23 | Regular |
| 3.5 L 6-cyl | Automatic (S4) | Front-Wheel Drive | 19 | 26 | 21 | Regular |
Want the full repair deets? Get the factory manual.
Recall and complaint data tells you what goes wrong. A service manual tells you how to fix it: torque specs, wiring diagrams, fluid capacities and step-by-step procedures for the 2005 Pontiac G6.
Closest thing to the factory manual for most years. Pay once, keep it.
Most $25–$78, one-timePro-shop repair procedures, wiring diagrams and TSBs for your exact car.
From $19.99/mo · $39.99/yrOEM procedures, specs and recall/TSB info, the same source many shops use.
From $19.99/mo · $59.99/yrStep-by-step photos written from a real teardown. Great for first-timers.
Books ~$30–$40 · AllAccess $34.99/moHeads up: we may earn a commission if you buy through these links, at no extra cost to you. Prices checked 2026-10 and can change. We never host or link to pirated manuals. Disclosure
FAQ
Does the 2005 Pontiac G6 have any recalls?
Yes. NHTSA lists 5 vehicle recalls for the 2005 Pontiac G6, plus 1 equipment or tire recalls that can apply. Recall repairs are free at any dealer, no matter how old the car is. Check your VIN at nhtsa.gov/recalls.
What are the most common 2005 Pontiac G6 problems?
Owners have filed 679 complaints with NHTSA. The most-reported areas are steering (459), electrical (86), exterior lights (62).
What gas mileage does the 2005 Pontiac G6 get?
EPA ratings run up to 23 mpg combined (3.5 L, Automatic 4-spd), across 2 engine and transmission combos.
Where can I get a 2005 Pontiac G6 repair manual?
eManualOnline sells downloadable manuals, Mitchell 1 DIY and ALLDATAdiy sell online access to factory repair data, and Haynes sells printed guides and online access. Pick a download if you want to keep it, or a subscription for wiring diagrams and TSBs.