Coachmen Freedom problems & recalls

Problem: Coachmen is recalling 13,662 my 2002-2008 motor homes, fifth wheel and travel trailers equipped with glass shower doors and manufactured from june 15, 2001 thorugh august 6, 2007. when pressure is applied to the towel bar on the glass shower door, the edge of the bar may contact the glass.

Risk: Glass breakage may occur which could cause personal injury.

Fix: Owners will be provided with new mounting hardware for the towel bar and installation instructions. if an owner is not comfortable replacing the hardware themselves, a dealer will install the hardware at no cost to them. the recall is expected to begin on or about december 19, 2008. owners may contact coachmen at 1-574-825-5821.

Problem: Coachmen is recalling 37,293 motorhomes and fifth wheel travel trailers equipped with a two-door refrigerator manufactured by the dometic corporation. the refrigerator may have a defect in the boiler tube. pressurized coolant solution could be released into an area where an ignition source (gas flame) is present.

Risk: Extended operation of a leaking cooling unit could lead to a fire from gas which might escape.

Fix: Coachmen is working with dometic in order to repair these refrigerators (please see 08e032). dometic will repair these refrigerators by installing a secondary burn housing, a thermal fuse, and a melt fuse free of charge. dometic has retained stericycle inc. to manage this campaign. stericycle will assist the owner in locating dealerships or service centers and will provide assistance with sche

Problem: On motor homes built on ford e-series chassis, the air filter element material process resulted in an air filter paper element that can smolder or burn. this change in filter paper composition combined with the configuration of the air induction system, may allow hot carbon particles to contact the air filter element during certain driving conditions that create hot particles.

Risk: These hot particles may ignite the air filter element with the potential for air induction system damage or underhood fire.

Fix: Ford is conducting the owner notification and remedy for this campaign. dealers will inspect and replace the air filter element. owners should contact ford at 1-800-392-3673 or coachmen at 219-825-5821.

Problem: On certain motor homes, travel trailers, and fifth wheel trailers equipped with samsung microwave ovens, these units were produced with a defective panel. an electrical short can occur between circuit patterns on the membrane panel, especially overlapped by a "jumper" or jump wire. this may cause the oven to activate without pressing any key pads.

Risk: An electrical short can occur causing the oven to activate without pressing any key pads. this could result in excessive heat, smoke, or possibly a fire.

Fix: Samsung will notify customers and repair the panel free of charge. in the meantime, consumers should unplug their microwave, if possible. if the consumer is unable to unplug the microwave, they should leave the door ajar until the panel is replaced. consumers should never use the microwave oven for storage or leave any towels, paper, cloth or other products in the microwave after use. owners w

Problem: On certain class c mini-motor homes built on 2003 chevrolet chassis, the chassis fuel return line, which is tapped to supply fuel to the generator, has been found to have pressures that exceed the maximum allowed by the generator manufacturer.

Risk: As a result, if the generator is operated at the same time the chassis engine is running, excess fuel could be delivered to the generator, creating a potential for a generator stall and possible fuel spill. in the event of a fuel spill, a fire could occur.

Fix: Dealers will install an approved kit that draws the generator fuel supply directly from the fuel tank. owner notification is began march 24, 2003. owners who take their vehicles to an authorized dealer on an agreed upon service date and do not receive the free remedy within a reasonable time should contact coachmen at 1-800-453-6064.