2002 Coachmen Rendezvous problems & recalls
NHTSA recalls and owner complaints for the 2002 Coachmen Rendezvous.
Recalls filed by Coachmen
Service Brakes, Hydraulic #03V040000 · 2003 · 3,539 units
Problem: Certain motor home chassis fail to comply with the requirements of federal motor vehicle safety standard no. 105, "hydraulic and electric brake systems." the brake system warning indicator may not function as required by standard.
Risk: In some of the affected vehicles, the brake system warning indicator will not illuminate when the ignition is in the start position or for a low brake fluid condition, if the body builder relied solely upon ford's ivm compliance statement for the brake system warning indicator.
Fix: Dealers will repair the brake warning lamp circuit. owner notification began march 24, 2003. owners who take their vehicles to an authorized dealer on an agreed upon service date and do not receive the free remedy within a reasonable time should contact coachmen at 1-219-825-5821.
Equipment #03V373000 · 2003 · 19,110 units
Problem: On certain motor homes, travel trailers, and fifth wheel trailers equipped with samsung microwave ovens, these units were produced with a defective panel. an electrical short can occur between circuit patterns on the membrane panel, especially overlapped by a "jumper" or jump wire. this may cause the oven to activate without pressing any key pads.
Risk: An electrical short can occur causing the oven to activate without pressing any key pads. this could result in excessive heat, smoke, or possibly a fire.
Fix: Samsung will notify customers and repair the panel free of charge. in the meantime, consumers should unplug their microwave, if possible. if the consumer is unable to unplug the microwave, they should leave the door ajar until the panel is replaced. consumers should never use the microwave oven for storage or leave any towels, paper, cloth or other products in the microwave after use. owners w
Service Brakes, Hydraulic #04V518000 · 2004 · 238 units
Problem: On motor home chassis built by workhorse and equipped with bosch brakes, the pads can drag on the rotor surface due to the pin slide.
Risk: A hang up or lock up may cause the calipers to over heat and not allow the driver to stop safely. this could cause overheating of the brake calipers which could result in a vehicle fire.
Fix: Workhorse is conducting the owner notification and remedy for this campaign. dealers will repair the brake caliper. owners should contact workhorse at 1-877-294-6773 or coachmen at 219-825-5821.
Recalls can cover only some VINs. Check yours at nhtsa.gov/recalls.
What owners complain about
No owner complaints filed with NHTSA for this model year.
Fix it, equip it, or try one first
Replacement parts for the systems owners report most: water, LP gas, slide-outs, electrical.
RV makers post owner manuals free; chassis service manuals (Ford, Freightliner) are sold separately.
Rent one from an owner to test it on a real trip.
Heads up: we may earn a commission if you buy through these links, at no extra cost to you. Disclosure
Specs
Specs coming soon. We only publish specs taken from the manufacturer's own brochures and spec sheets.
Other years
FAQ
Does the 2002 Coachmen Rendezvous have recalls?
NHTSA lists 3 recalls filed by Coachmen for the 2002 Rendezvous. Check your VIN at nhtsa.gov/recalls to see if a fix is still open.
What are the most common 2002 Coachmen Rendezvous problems?
No owner complaints have been filed with NHTSA for this model year.