Holiday Rambler Endeavor problems & recalls

Problem: Rev recreation group (rev) is recalling certain 2022-2024 fleetwood discovery and holiday rambler endeavor motorhomes, equipped with remco 50-54 rebel 4.0 gpm water pumps. the water pump harness was designed with inadequate fuse protection.

Risk: Inadequate fuse protection may cause harness damage, increasing the risk of a fire.

Fix: Dealers will inspect and relocate the water pump circuit to a properly sized fuse as necessary, free of charge. owner notification letters were mailed june 15, 2024. owners may contact rev customer service at 1-800-509-3417. rev's number for this recall is 240416rev.

Problem: Rev recreation group (rev) is recalling certain 2023 fleetwood bounder, flair, flex, fortis, southwind, discovery, discovery lxe, frontier, frontier gtx, pace arrow, holiday rambler admiral, eclipse, invicta, vacationer, armada, endeavor, navigator, nautica, and american coach american tradition motorhomes. the entry door latch may fail and not allow entry or exit.

Risk: The inability to enter or exit the vehicle in an emergency increases the risk of injury.

Fix: Dealers will inspect and if necessary, replace the door latch, free of charge. owner notification letters were mailed may 12, 2023. owners may contact rev customer service at 1-800-509-3417. rev's number for this recall is 230224rev.

Problem: Rev recreation group (rev) is recalling certain 2018-2019 fleetwood jamboree, 2020-2023 fleetwood southwind, bounder, flair, fortis, holiday rambler admiral, invicta, vacationer, 2021-2023 fleetwood discovery, discovery lxe, holiday rambler navigator, armada, nautica, 2023 fleetwood flex, holiday rambler eclipse, 2021 fleetwood pace arrow lxe, 2018 holiday rambler vesta, 2022-2023 fleetwood frontier, 2021-2022 fleetwood pace arrow, holiday rambler endeavor, and 2019 holiday rambler augusta motorhomes. the hydraulic lines may have been improperly routed, secured, or protected, which can result in a hydraulic fluid leak.

Risk: A hydraulic fluid leak in the presence of an ignition source can increase the risk of a fire.

Fix: Dealers will inspect the hydraulic hoses for chafing or heat damage, and install hose protection, or replace them as necessary, free of charge. owner notification letters were mailed october 28, 2022. owners may contact rev customer service at 1-800-509-3417.

Problem: Rev recreation group (rev) is recalling certain 2021 fleetwood discovery, discovery lxe, pace arrow, pace arrow lxe, bounder, and southwind and holiday rambler armada, endeavor, nautica, navigator, and vacationer motorhomes. the primary gear of the bed lift motor may fail, allowing the bed frame to drop.

Risk: A bed frame that drops can increase the risk of an injury.

Fix: Rev will notify owners, and dealers will inspect, and if necessary, replace the bed lift motor, free of charge. the recall is expected to begin january 12, 2021. owners may contact rev customer service at 1-800-509-3417. rev's number for this recall is 201109rev.

Problem: Rev recreation group (rev) is recalling certain 2020 fleetwood pace arrow lxe, discovery and discovery lxe, and holiday rambler navigator and endeavor motorhomes. the wire harness/plumbing bundle within the slideout raceway may have been improperly wrapped and secured.

Risk: Without the proper securement, the wire harness/plumbing bundle can become damaged, increasing the risk of a fire.

Fix: Rev will notify owners, and dealers will inspect, repair, reroute and resecure the wire harness/plumbing bundle, free of charge. the recall began january 31, 2020. owners may contact rev customer service at 1-800-509-3417. rev's number for this recall is 191126rev.

Problem: Rev recreation group (rev) is recalling certain 2018 fleetwood axon and pulse, holiday rambler reno and prodigy, monaco marquis and american coach american dream motorhomes, 2017-2018 fleetwood bounder, discovery, discovery lxe, flair, jamboree, southwind, pace arrow, pace arrow lxe and storm motorhomes, holiday rambler admiral xe, endeavor, endeavor xe, navigator xe, navigator, vacationer, vacationer xe and vesta and american coach american eagle motorhomes and 2017 holiday rambler scepter, monaco diplomat, and american coach american revolution motorhomes. the mounting screws for the satellite dish may not have been fastened through the sheet steel reinforcement, possibly allowing the sat

Risk: If the satellite dish detaches from the roof while driving, it can increase the risk of a crash or injury.

Fix: Rev will notify owners, and dealers will resecure the satellite dish to the roof with a metal reinforcement, free of charge. the recall began on may 14, 2018. owners may contact rev customer service at 1-800-509-3417. rev's number for this recall is 180322rev. note: this recall supersedes recall 17v-802. any vehicle repaired under that campaigned is not included in this one as the remedy for

Problem: Rev recreation group (rev) is recalling certain 2018 american coach american dream and american revolution motorhomes, fleetwood discovery, discovery lxe, pace arrow and pace arrow lxe motorhomes, holiday rambler endeavor, endeavor xe, navigator and navigator xe motorhomes and monaco marquis and signature motorhomes equipped with an aurora heating, ventilation and air conditioning (hvac) system. the wires for the hvac system potentiometer may become disconnected from the quick connect terminals.

Risk: If the potentiometer wires detach and are reconnected incorrectly, there is an increased risk of a fire.

Fix: Rev will notify owners, and dealers will inspect the potentiometer and solder the wires or replace the control panel, if necessary, free of charge. the recall began on may 14, 2018. owners may contact rev customer service at 1-800-509-3417. rev's number for this recall is 180315rev.

Problem: Rev recreation group (rev) is recalling certain 2018 american coach american dream, american revolution, fleetwood discovery, discovery lxe, holiday rambler endeavor, endeavor xe, and monaco marquis recreational vehicles. water may enter the 12-volt harness connectors due to missing gaskets or the placement of the pin connectors, potentially causing an electrical short.

Risk: An electrical short can increase the risk of a crash.

Fix: Rev recreation group will notify owners, and dealers will inspect, and if necessary, install a gasket for each affected harness pin connector and re-route harnesses that terminate near luggage compartment number five, free of charge. the recall began on february 15, 2018. owners may contact rev customer service at 1-800-509-3417. rev's number for this recall is 171213rev.

Problem: Rev recreation group (rev) is recalling certain 2009-2010 and 2012-2014 holiday rambler ambassador, 2010 and 2013-2014 endeavor, 2009-2010 neptune, 2010 scepter, and 2011 trip diesel motorhomes, equipped with kidde plastic-handle or push button 'pindicator' fire extinguishers. these extinguishers may become clogged, preventing the extinguisher from discharging as expected or excessive force may be needed to activate the extinguisher. additionally, in certain models, the nozzle may detach from the valve assembly with enough force that it could cause injury and also render the product inoperable. for a full list of the affected fire extinguisher models visit: https://static.nhtsa.gov/odi/rc

Risk: In the event of a fire, if the fire extinguisher does not function properly, it can increase the risk of injury.

Fix: Rev will notify owners, and instruct them to contact kidde for a replacement fire extinguisher, free of charge. the recall is expected to begin january 18, 2018. owners may contact rev customer service at 1-800-509-3417, or kidde customer service at 1-855-262-3540 or online at www.kidde.com and click on "product safety recall" for more information.

Problem: Rev recreation group (rev) is recalling certain 2017-2018 fleetwood discovery and discovery lxe, and holiday rambler endeavor, endeavor xe, and admiral xe motorhomes, as well as 2018 monaco diplomat, fleetwood pace arrow, bounder, flair, and storm motorhomes, and holiday rambler navigator and vacationer xe motorhomes. the affected vehicles may have been manufactured with headlights that do not have tempered glass lenses.

Risk: If the headlamp lens is not tempered, it may crack or break, which may cause decreased illumination and/or premature failure of the headlight bulb, increasing the risk of a crash.

Fix: Rev recreation group will notify owners, and authorized rev dealers will inspect, and if necessary, replace non-tempered, defective headlamp lenses with new headlamp lenses, free of charge. the recall began on september 8, 2017. owners may contact rev customer service at 1-800-509-3417. revs number for the recall is 170720rev.

Problem: Rev recreation group (rev) is recalling certain model year 2016-2017 holiday rambler endeavor motor homes, models 40dp, 40g, 40e, 40g and 40x, manufactured november 23, 2015, to april 7, 2016, and holiday rambler endeavor xe motor homes , model 37pe, manufactured november 17, 2015, to april 6, 2016. the affected vehicles have a section of framework that may rub, or cause the mud flap to rub, against the front passenger-side tire, resulting in excessive tire wear. additionally, steering may be restricted.

Risk: Excessive tire wear may result in tire failure. restricted steering can affect control of the vehicle. either condition increases the risk of a crash.

Fix: Rev will notify owners, and dealers will inspect the tube steel skirt framing and remove the diagonal section if present, and install additional screws to secure the mud flap. this repair will be done free of charge. the recall began on june 14, 2016. owners may contact rev customer service at 1-800-509-3417. rev's number for this recall is 160429rev.

Problem: Allied recreation group, inc. (arg) is recalling certain model year 2010-2011 holiday rambler admiral, 2009-2014 holiday rambler ambassador, 2010 holiday rambler arista, 2010-2014 holiday rambler endeavor, 2009-2011 holiday rambler neptune, 2011-2014 holiday rambler vacationer, 2009-2011 monaco cayman, 2010-2014 monaco diplomat, 2014 monaco dynasty, 2009-2014 monaco knight, 2012-2013 monaco lapalma, 2009-2013 monaco monarch, 2009-2011 monaco riptide, 2008 safari passage, and 2008 safari simba motorhomes. the affected vehicles are equipped with certain lippert-brand coachstep double electric steps. these steps use a bolt to attach the fan gear assembly to the steps. this bolt may fracture

Risk: Unstable entry and exit steps increase the risk of injury.

Fix: Arg will notify owners and dealers will install a retainer bracket to reinforce the operating mechanism, free of charge. the recall began on february 12, 2016. owners may contact arg customer service number at 1-800-509-3417. arg's number for this recall is 151216rev.