2004 Itasca Suncruiser problems & recalls
NHTSA recalls and owner complaints for the 2004 Itasca Suncruiser.
Built on
- Workhorse W22 (Incomplete - Motor Home Chassis): 6 of 6 decoded VINs · 2 NHTSA recalls filed by Workhorse for the 2004 W22
Decoded with NHTSA vPIC from the partial VINs owners included in complaints. For motorhomes, engine, brake and steering recalls are filed by the chassis maker and are not counted in the Itasca recalls above. Check your VIN at nhtsa.gov/recalls to see both.
Recalls filed by Itasca
Seat Belts #04V608000 · 2004 · 6,201 units
Problem: Certain seat belt buckles on some motor homes fail to conform to the load requirement of federal motor vehicle safety standard no. 209, "seat belt assemblies."
Risk: The seat belt buckle may unlatch in the event of a vehicle crash, possibly resulting in personal injury to the seat occupant.
Fix: Dealers will replace the buckles. the recall began on november 12, 2004. owners should contact amsafe at 1-574-266-8330 or winnebago at 1-800-537-1885.
Fuel System, Gasoline #04V609000 · 2004 · 3,538 units
Problem: On certain motor homes built on a 20,700 gvwr or greater workhorse chassis, there may not be sufficient clearance in the area where the fuel line crosses the frame cross member.
Risk: Without clearance, a condition could develop where the cross member may wear into the fuel line and a fuel leak may develop. fuel leakage, in the presence of an ignition source, could result in a fire.
Fix: Dealers will repair these motor homes by providing clearance between the fuel line and frame cross member. the fuel line will be inspected and, if necessary, replaced. the recall began january 7, 2005. owners should contact winnebago at 1-800-537-1885.
Equipment #10V525000 · 2010 · 18,461 units
Problem: Winnebago is recalling certain recreational vehicles equipped with 1200-series norcold refrigerators. the population of refrigerators being addressed contains either a sensing algorithm or thermal switch to shut off power to the refrigerator when high temperatures are detected in order to prevent a potential fire. the response times of the sensor algorithm and thermal switch devices to stop power are not sufficient.
Risk: The sensing algorithm or thermal switch installed to shut off power to the refrigerator when high temperatures are detected due to a possible hydrogen gas leak may not shut off in sufficient time to prevent a fire.
Fix: Winnebago is working with norcold to identify and notify any affected owners. owners will be instructed to contact norcold dealers to receive the remedy free of charge. please see norcold's defect report 10e-049 for additional information. the recall began during december 2010. owners may contact norcold at 1-800-767-9101 or winnebago at 1-641-585-3535.
Recalls can cover only some VINs. Check yours at nhtsa.gov/recalls.
What owners complain about
Components named in 6 NHTSA owner complaints. Complaints are unverified.
Fix it, equip it, or try one first
Replacement parts for the systems owners report most: water, LP gas, slide-outs, electrical.
RV makers post owner manuals free; chassis service manuals (Ford, Freightliner) are sold separately.
Rent one from an owner to test it on a real trip.
Heads up: we may earn a commission if you buy through these links, at no extra cost to you. Disclosure
Specs
Specs coming soon. We only publish specs taken from the manufacturer's own brochures and spec sheets.
Other years
FAQ
Does the 2004 Itasca Suncruiser have recalls?
NHTSA lists 3 recalls filed by Itasca for the 2004 Suncruiser. Check your VIN at nhtsa.gov/recalls to see if a fix is still open.
What are the most common 2004 Itasca Suncruiser problems?
In 6 owner complaints filed with NHTSA, the most-named area is service brakes, hydraulic.