2009 Toyota Highlander: Recalls, Problems & MPG
Here are the deets on the 2009 Toyota Highlander: 9 recalls, 134 owner complaints and up to 22 mpg combined.
Recalls
9 vehicle recalls from the manufacturer. Repairs are free. Check your VIN to see if one is still open on your car.
Equipment Vehicle recall #09V223000 · 2009 · 27,080 vehicles
What's wrong: These vehicles were not equipped with load carrying capacity modification labels which fails to conform with the requirements of Federal Motor Vehicle Safety Standard no. 110, "tire selection and rims."
Why it matters: Incorrect load carrying capacity modification labels could result in the vehicle being overloaded, increasing the risk of a crash.
The fix: Toyota will notify owners and provide them with a new, accurate label to be installed over the inaccurate label free of charge. The safety recall began on August 18, 2009.
Speed control / throttle Vehicle recall #10V023000 · 2010 · 1,126,915 vehicles
What's wrong: The accelerator pedal can get stuck in the wide open position due to its being trapped by an unsecured or incompatible driver's floor mat. This recall is an expansion of a campaign of 3.8 million other Toyota vehicles announced in 2009 for the same issue (see 09v-388).
Why it matters: A stuck open accelerator pedal May result in very high vehicle speeds and make it difficult to stop the vehicle, which could cause a crash, serious injury or death.
The fix: Toyota will modify or replace the accelerator pedals on the subject vehicles. Floor surface modifications are also being considered and will be included for any model for which it is deemed appropriate. Initially, dealers will be instructed on how to reshape the accelerator pedal for the repair. As…
Equipment Vehicle recall #10V035000 · 2010 · 271,417 vehicles
What's wrong: 110, "tire selection and rims." these vehicles were sold between September 1, 2005 and June 2, 2008 without the requisite load carrying capacity modification labels.
Why it matters: This does not meet the standard requirements.
The fix: Dealers will mail to consumers the corrected label or the customer will have the option for dealers to install the label free of charge. Dealers will also correct the owner's manual. The safety recall began on May 27, 2010.
Equipment Vehicle recall #10V036000 · 2010 · 153,418 vehicles
What's wrong: 110, "tire selection and rims." these vehicles were sold without the requisite load carrying capacity modification labels.
Why it matters: A driver May overload a vehicle which May increase the risk of a crash.
The fix: Dealers will mail to consumers the corrected label or the customer will have the option for dealers to install the label free of charge. The safety recall began on May 27, 2010.
Seats, Airbags Vehicle recall #13V014000 · 2013 · 3,235 vehicles
What's wrong: During modification by set to include accessories such as leather seat covers, seat heaters or headrest dvd systems, these vehicles May not have had the passenger seat occupant sensing system calibration tested. Without passing the calibration test, the occupant sensing system May not operate as designed.
Why it matters: If the front passenger seat occupant sensing system is out of calibration, the front passenger airbags May not deploy or they May deploy inappropriately for the passenger's size and position. This could increase the risk of personal injury during the event of a vehicle crash necessitating airbag…
The fix: Southeast Toyota will notify owners, and dealers will test the sensitivity of the occupant detection sensors, and recalibrate them as necessary. The recall began on March 21, 2013.
Airbags Vehicle recall #14V168000 · 2014 · 1,486,413 vehicles
What's wrong: In the affected vehicles, the steering column assembly contains electrical connections to the driver's airbag module housed in a spiral cable assembly, which includes a flexible flat cable (ffc). Due to the shape and location of the ffc's retainer, the ffc could become damaged when the steering wheel is turned.
Why it matters: If the ffc is damaged, connectivity to the driver's air bag module could be lost and the air bag deactivated. The failure of the driver's air bag to deploy in the event of a crash that typically necessitates deployment increases the risk of injury to the driver.
The fix: Toyota will notify the Toyota vehicle owners, and general motors will notify the Pontiac vibe owners. Toyota sent owners an interim notification letter in May 2014 to advise owners of the recall. Toyota will mail owners a second letter when remedy parts are available. General motors sent Pontiac…
Seats Vehicle recall #14V743000 · 2014 · 3,233 vehicles
What's wrong: The affected vehicles May experience compression of the seat cushion which May damage the seat heater wiring.
Why it matters: Damage to the seat heater wiring could cause the wires to short, increasing the risk of the seat burning and causing personal injury to the occupant.
The fix: Set will notify owners, and dealers will disconnect the heaters with copper strand heating elements and refund the purchase price of the seat heater accessory, free of charge. The recall is expected to began in January 2015.
Visibility (wipers, glass) Vehicle recall #15V689000 · 2015 · 1,814,284 vehicles
What's wrong: During the manufacturing of the power window master switch (pwms), grease lubricant May have been inconsistently applied to the sliding electrical contacts.
Why it matters: If the sliding electrical contacts are not protected by lubricant, debris and moisture that get into the switch May cause a short circuit and the switch assembly May overheat and melt, increasing the risk of a fire.
The fix: Toyota will notify owners, and dealers will inspect the switch, applying a lubricant if no abnormality is found. If abnormality is found, the pwms circuit board will be replaced, free of charge. The recall is expected to begin December 20, 2015.
Seats Vehicle recall #16V396000 · 2016 · 7,749 vehicles
What's wrong: The electrical wiring in the seat heaters May be damaged when the seat cushion is compressed.
Why it matters: If damaged, the copper strand heating element May short circuit, increasing the risk of a fire.
The fix: Set will notify owners, and dealers will disconnect the seat heaters, free of charge, and refund the purchase price of the seat heater accessory. The recall began on July 14, 2016.
Most-reported problems
Owner complaints filed with NHTSA, by component. One complaint can list several components. 5 mention a fire, 9 injuries and 0 deaths were reported.
What owners describe
- Engine (23): the most common themes are noise or vibration (9), leaks (7), warning light on (6).
- Brakes (21): the most common themes are warning light on (11), noise or vibration (5).
- Electrical (20): the most common themes are door / lock issues (12), electrical failure (6), fire / smoke (2).
- Body & structure (15): the most common themes are door / lock issues (10), noise or vibration (4).
The 2009 Toyota Highlander has 134 owner complaints, ranking #21 of 28 Highlander model years for complaints (about average; the typical year has 205). Complaints peaked in 2010 (21 filed that year). The typical problem showed up when the car was about 6 years old, at a median of 60,000 miles. Neighboring years: 2008 (404 complaints, 11 recalls), 2010 (216 complaints, 10 recalls).
Engines & fuel economy (EPA)
| Engine | Transmission | Drive | City | Hwy | Comb. | Fuel |
|---|---|---|---|---|---|---|
| 2.7 L 4-cyl | Automatic (S6) | Front-Wheel Drive | 20 | 27 | 22 | Regular |
| 3.5 L 6-cyl | Automatic (S5) | Front-Wheel Drive | 18 | 24 | 20 | Regular |
| 3.5 L 6-cyl | Automatic (S5) | 4-Wheel or All-Wheel Drive | 17 | 23 | 19 | Regular |
Want the full repair deets? Get the factory manual.
Recall and complaint data tells you what goes wrong. A service manual tells you how to fix it: torque specs, wiring diagrams, fluid capacities and step-by-step procedures for the 2009 Toyota Highlander.
Closest thing to the factory manual for most years. Pay once, keep it.
Most $25–$78, one-timePro-shop repair procedures, wiring diagrams and TSBs for your exact car.
From $19.99/mo · $39.99/yrOEM procedures, specs and recall/TSB info, the same source many shops use.
From $19.99/mo · $59.99/yrStep-by-step photos written from a real teardown. Great for first-timers.
Books ~$30–$40 · AllAccess $34.99/moHeads up: we may earn a commission if you buy through these links, at no extra cost to you. Prices checked 2026-10 and can change. We never host or link to pirated manuals. Disclosure
FAQ
Does the 2009 Toyota Highlander have any recalls?
Yes. NHTSA lists 9 vehicle recalls for the 2009 Toyota Highlander. Recall repairs are free at any dealer, no matter how old the car is. Check your VIN at nhtsa.gov/recalls.
What are the most common 2009 Toyota Highlander problems?
Owners have filed 134 complaints with NHTSA. The most-reported areas are engine (23), brakes (21), electrical (20).
What gas mileage does the 2009 Toyota Highlander get?
EPA ratings run up to 22 mpg combined (2.7 L, Automatic (S6)), across 3 engine and transmission combos.
Where can I get a 2009 Toyota Highlander repair manual?
eManualOnline sells downloadable manuals, Mitchell 1 DIY and ALLDATAdiy sell online access to factory repair data, and Haynes sells printed guides and online access. Pick a download if you want to keep it, or a subscription for wiring diagrams and TSBs.