2000 Volvo S80: Recalls, Problems & MPG
Here are the deets on the 2000 Volvo S80: 4 recalls, 318 owner complaints and up to 19 mpg combined.
Recalls
4 vehicle recalls from the manufacturer, plus 1 equipment/tire recall that can apply. Repairs are free. Check your VIN to see if one is still open on your car.
Suspension Vehicle recall #00V238000 · 2000 · 49,488 vehicles
What's wrong: Over time, the ball joint between the front wheel king pin and the suspension link arm, can experience increased looseness.
Why it matters: This condition could affect the ball joint's durability and performance.
The fix: Dealers will replace both front ball joints.
Engine & cooling Vehicle recall #04V451000 · 2004 · 149,799 vehicles
What's wrong: On certain passenger and sport utility vehicles, under certain operating conditions, some electric cooling fans May overheat potentially causing heat damage and, in rare instances, a fire in the engine compartment.
Why it matters: A fire in the engine compartment could occur.
The fix: Dealers will replace the cooling fan. The recall began on November 29, 2004. Customers should contact Volvo cars at 1-800-458-1552.
Speed control / throttle Vehicle recall #06V441000 · 2006 · 170,099 vehicles
What's wrong: On certain passenger vehicles, a combination of throttle positioning sensor irregularities, a dirty throttle housing, and/or inefficient software calibration May cause a warning lamp to light and the subsequent onset of limp home modes.
Why it matters: This resulted in a high number of vehicles going into the limp home mode without need.
The fix: Dealers will install the current software upgrade onto the involved vehicles. The recall began on December 29, 2006.
Equipment Vehicle recall #10V566000 · 2010 · 416 vehicles
What's wrong:
Why it matters: An overheated battery could lead to a fire.
The fix: Volvo advises owners to please stop using the garmin portable gps device immediately, and visit the garmin website to determine if their unit is affected. The unit's battery will be replaced with a new battery and a spacer will be inserted on top of the battery next to the pcb. This service will be…
1 aftermarket equipment / tire recall replacement parts sold to fit this car, not the car itself
Brakes (hydraulic) Equipment recall #07E023000 · 2007 · 13,128 vehicles
What's wrong: Certain cardone master cylinders with part numbers 10-2925, 10-2987, 10-2987mza, 10-3083, 11-3015, 11-3042, 11-3044, 11-3045, 11-3047, 11-3064, and 11-3156, and with date codes lower than dca7078 sold as replacement equipment for use on the vehicles listed above. The seal on master cylinder can fail and leak brake fluid.
Why it matters: Loss of brake fluid can result in poor braking performance, possibly resulting in a vehicle crash.
The fix: Cardone will notify owners and offer to repurchase any defective master cylinders. The recall began during April 2007. Owners can contact cardone at 1-800-777-4780.
Most-reported problems
Owner complaints filed with NHTSA, by component. One complaint can list several components. 8 mention a fire, 13 injuries and 0 deaths were reported.
What owners describe
- Speed control / throttle (93): the most common themes are stalls / loses power (47), sudden acceleration (16).
- Engine & cooling (68): the most common themes are stalls / loses power (36), warning light on (15).
- Electrical (54): the most common themes are stalls / loses power (24), electrical failure (12).
- Fuel system (34): the most common themes are stalls / loses power (13), leaks (9).
The 2000 Volvo S80 has 318 owner complaints, ranking #1 of 18 S80 model years for complaints (6.0× the average S80 year). Complaints peaked in 2005 (107 filed that year). The typical problem showed up when the car was about 5 years old, at a median of 78,000 miles. Neighboring years: 1999 (199 complaints, 4 recalls), 2001 (164 complaints, 7 recalls).
Engines & fuel economy (EPA)
| Engine | Transmission | Drive | City | Hwy | Comb. | Fuel |
|---|---|---|---|---|---|---|
| 2.9 L 6-cyl | Automatic 4-spd | Front-Wheel Drive | 16 | 24 | 19 | Premium |
| 2.8 L 6-cyl turbo | Automatic 4-spd | Front-Wheel Drive | 16 | 23 | 18 | Premium |
Want the full repair deets? Get the factory manual.
Recall and complaint data tells you what goes wrong. A service manual tells you how to fix it: torque specs, wiring diagrams, fluid capacities and step-by-step procedures for the 2000 Volvo S80.
Closest thing to the factory manual for most years. Pay once, keep it.
Most $25–$78, one-timePro-shop repair procedures, wiring diagrams and TSBs for your exact car.
From $19.99/mo · $39.99/yrOEM procedures, specs and recall/TSB info, the same source many shops use.
From $19.99/mo · $59.99/yrStep-by-step photos written from a real teardown. Great for first-timers.
Books ~$30–$40 · AllAccess $34.99/moHeads up: we may earn a commission if you buy through these links, at no extra cost to you. Prices checked 2026-10 and can change. We never host or link to pirated manuals. Disclosure
FAQ
Does the 2000 Volvo S80 have any recalls?
Yes. NHTSA lists 4 vehicle recalls for the 2000 Volvo S80, plus 1 equipment or tire recalls that can apply. Recall repairs are free at any dealer, no matter how old the car is. Check your VIN at nhtsa.gov/recalls.
What are the most common 2000 Volvo S80 problems?
Owners have filed 318 complaints with NHTSA. The most-reported areas are speed control / throttle (93), engine & cooling (68), electrical (54).
What gas mileage does the 2000 Volvo S80 get?
EPA ratings run up to 19 mpg combined (2.9 L, Automatic 4-spd), across 2 engine and transmission combos.
Where can I get a 2000 Volvo S80 repair manual?
eManualOnline sells downloadable manuals, Mitchell 1 DIY and ALLDATAdiy sell online access to factory repair data, and Haynes sells printed guides and online access. Pick a download if you want to keep it, or a subscription for wiring diagrams and TSBs.