1998 Chevrolet Monte Carlo: Recalls, Problems & MPG
Here are the deets on the 1998 Chevrolet Monte Carlo: 3 recalls, 100 owner complaints and up to 21 mpg combined.
Recalls
3 vehicle recalls from the manufacturer, plus 2 equipment/tire recalls that can apply. Repairs are free. Check your VIN to see if one is still open on your car.
Steering Vehicle recall #03V527000 · 2003 · 750,283 vehicles
What's wrong: Certain passenger vehicles have lower pinion bearings in the power rack and pinion assembly in which the retainer tabs were not crimped properly. These retainers could fail and permit the ball bearings to escape.
Why it matters: If this occurs, the pinion shaft can be forced upward during left turns and back down as the steering wheel is moved back and to the right. If the pinion shaft moves further, the driver will need to exert more effort to turn the steering wheel, similar to a vehicle without power assisted steering.…
The fix: Dealers will install a new lower pinion bearing unless inspect of the existing bearing indicates that replacement of the gear assembly is necessary. Owner notification began on February 5, 2004. Owners should contact Buick at 1-866-608-8080; Chevrolet at 1-800-630-2438; Oldsmobile at…
Engine & cooling Vehicle recall #09V116000 · 2009 · 1,497,516 vehicles
What's wrong: 8l v6 naturally aspirated engine. Some of these vehicles have a condition in which drops of engine oil May be deposited on the exhaust manifold through hard braking.
Why it matters: If the manifold is hot enough and the oil runs below the heat shield, it May ignite into a small flame and May spread to the plastic spark plug wire channel and beyond increasing the risk of an engine compartment fire.
The fix: Dealers will replace the engineâs front valve cover and front-valve-cover gasket with new parts of an improved design and remove the engineâs plastic cover and plastic oil-fill-tube extension, free of charge. The recall is expected to begin during May 2016.
Engine & cooling, Engine & cooling Vehicle recall #15V701000 · 2015 · 1,003,556 vehicles
What's wrong: The affected vehicles were previously repaired under recalls 08v-118, 09v-116, and 15v-201 to address the possibility that engine oil May drip onto the hot exhaust manifold.
Why it matters: Engine oil that drips onto the hot surface of the exhaust manifold May result in a fire.
The fix: The remedy applied under recalls 08v-118, 09v-116, and 15v-201 did not adequately remove the safety risk. Under the improved remedy, dealers will replace the engineâs front valve cover and gasket. Vehicles that are covered by recalls 08v-118, 09v-116, or 15v-201 that have not yet received the…
2 aftermarket equipment / tire recalls replacement parts sold to fit this car, not the car itself
Brakes (hydraulic) Recall #01I014000 · 2001 · 0 vehicles
What's wrong: This is not a safety recall in accordance with the safety act. However, it is deemed a safety improvement campaign by the agency. Vehicle description: 1995-1999 Chevrolet monte carlo z34 passenger vehicles. The braking performance in wet weather or wet road conditions is reduced more than a driver would expect.
Why it matters: The braking could feel delayed momentarily when light or moderate force is applied on the brake pedal while driving on wet roads or after going through a car wash.
The fix: Dealer will modify the front fender liners to remove a portion of the closeout panels in the front wheel wells at no charge to the consumer. This service will be available through August 2004.
Fuel system (other) Equipment recall #07E021000 · 2007 · 742 vehicles
What's wrong: Certain delphi fuel pressure regulators, p/nos. Fp10020-11b1, fp10026-11b1, and fp10027-11b1, sold after January 9, 2007, as aftermarket equipment for various passenger vehicles listed above. The universal pressure regulators (upr) were produced without an o'ring and retainer.
Why it matters: Fuel May leak, possibly resulting in a fire.
The fix: Delphi will notify owners and replace the upr free of charge. The recall began on April 23, 2007. Owners can contact delphi at 877-411-8770.
Most-reported problems
Owner complaints filed with NHTSA, by component. One complaint can list several components. 8 mention a fire, 11 injuries and 7 deaths were reported.
What owners describe
- Brakes (hydraulic) (20): the most common themes are brake failure / soft pedal (4), noise or vibration (3).
- Steering (16): the most common themes are steering problems (10), noise or vibration (5).
- Engine & cooling (14): the most common themes are stalls / loses power (4), leaks (4), fire / smoke (3).
- Electrical (10): the most common themes are electrical failure (6), fire / smoke (4).
The 1998 Chevrolet Monte Carlo has 100 owner complaints, ranking #12 of 17 Monte Carlo model years for complaints (about average; the typical year has 125). Complaints peaked in 1999 (18 filed that year). The typical problem showed up when the car was about 5 years old, at a median of 86,000 miles. Neighboring years: 1997 (164 complaints, 1 recalls), 1999 (125 complaints, 3 recalls).
Engines & fuel economy (EPA)
| Engine | Transmission | Drive | City | Hwy | Comb. | Fuel |
|---|---|---|---|---|---|---|
| 3.1 L 6-cyl | Automatic 4-spd | Front-Wheel Drive | 17 | 27 | 21 | Regular |
| 3.8 L 6-cyl | Automatic 4-spd | Front-Wheel Drive | 17 | 27 | 21 | Regular |
| 3.8 L 6-cyl | Automatic 4-spd | Front-Wheel Drive | 16 | 25 | 19 | Regular |
Want the full repair deets? Get the factory manual.
Recall and complaint data tells you what goes wrong. A service manual tells you how to fix it: torque specs, wiring diagrams, fluid capacities and step-by-step procedures for the 1998 Chevrolet Monte Carlo.
Closest thing to the factory manual for most years. Pay once, keep it.
Most $25–$78, one-timePro-shop repair procedures, wiring diagrams and TSBs for your exact car.
From $19.99/mo · $39.99/yrOEM procedures, specs and recall/TSB info, the same source many shops use.
From $19.99/mo · $59.99/yrStep-by-step photos written from a real teardown. Great for first-timers.
Books ~$30–$40 · AllAccess $34.99/moHeads up: we may earn a commission if you buy through these links, at no extra cost to you. Prices checked 2026-10 and can change. We never host or link to pirated manuals. Disclosure
FAQ
Does the 1998 Chevrolet Monte Carlo have any recalls?
Yes. NHTSA lists 3 vehicle recalls for the 1998 Chevrolet Monte Carlo, plus 2 equipment or tire recalls that can apply. Recall repairs are free at any dealer, no matter how old the car is. Check your VIN at nhtsa.gov/recalls.
What are the most common 1998 Chevrolet Monte Carlo problems?
Owners have filed 100 complaints with NHTSA. The most-reported areas are brakes (hydraulic) (20), steering (16), engine & cooling (14).
What gas mileage does the 1998 Chevrolet Monte Carlo get?
EPA ratings run up to 21 mpg combined (3.1 L, Automatic 4-spd), across 3 engine and transmission combos.
Where can I get a 1998 Chevrolet Monte Carlo repair manual?
eManualOnline sells downloadable manuals, Mitchell 1 DIY and ALLDATAdiy sell online access to factory repair data, and Haynes sells printed guides and online access. Pick a download if you want to keep it, or a subscription for wiring diagrams and TSBs.