2007 Ford F-150: Recalls, Problems & MPG
Here are the deets on the 2007 Ford F-150: 2 recalls, 488 owner complaints and up to 16 mpg combined.
Recalls
2 vehicle recalls from the manufacturer, plus 5 equipment/tire recalls that can apply. Repairs are free. Check your VIN to see if one is still open on your car.
Fuel system Vehicle recall #07V278000 · 2007 · 203 vehicles
What's wrong: On certain trucks built with 26 gallon fuel tanks, the fuel tank May have a depression at the seam between the top and bottom halves of the tank (not visible from outside the fuel tank). If a depression is large enough, fuel May permeate the fuel tank wall resulting in a fuel odor, or a "service engine soon" indicator light.
Why it matters: If left uncorrected, a fuel leak could eventually develop. A fuel leak in the presence of an ignition source could result in a fire.
The fix: Dealers will replace the fuel tank free of charge. The recall began on June 25, 2007.
Engine & cooling Vehicle recall #08V523000 · 2008 · 213 vehicles
What's wrong: The hydro-carbon paper affixed to the inside of the airbox lid with adhesive May become dislodged during operation.
Why it matters: This failure May result in a loss of performance, illumination of the malfunction indicator lamp (mil) and, in extreme cases, a stalling of the vehicle during operation without notice, which could result in a crash.
The fix: Dealers will replace the airbox lid with a new one that includes the hydro-carbon paper which has been affixed using an adhesive promoter and greater pressure as recommended by the manufacturer free of charge. The recall began on October 21, 2008.
5 aftermarket equipment / tire recalls replacement parts sold to fit this car, not the car itself
Equipment Equipment recall #07E066000 · 2007 · 175 vehicles
What's wrong: Certain cequent 90 degree 7-way right angle adaptors sold by distributors in tow packages for aftermarket sales to tow 5th wheel rv travel trailers. Due to incorrect wiring of the harness, the trailer lights May not operate properly.
Why it matters: If the trailer lights are not working properly, a vehicle crash can occur.
The fix: All of the defective tow packages are still at the distributor level and have not been sold to any consumers.
Exterior lights Equipment recall #07E075000 · 2007 · 2,388 vehicles
What's wrong: Certain Eagle eyes headlamp assemblies, p/nos. Fr390-b001l and fr390-b001r, sold for use as replacement equipment for the above listed passenger vehicles. The thickness is unstable inhibiting the performance of the upper and lower beams which fails to conform to the photometric requirements of Federal Motor Vehicle Safety Standard no. 108, lamps, reflective devices, and associated equipment.
Why it matters: Decreased lighting visibility May result in a vehicle crash.
The fix: Eagle eyes will notify owners and offer reimbursement for any noncompliant headlights. The recall began on November 6, 2007.
Exterior lights Equipment recall #07E080000 · 2007 · 700 vehicles
What's wrong: Certain headlamp assemblies imported and sold as aftermarket equipment by sonar auto parts for use on 2004-2007 Ford f150 pickup trucks. During production, the headlamps were internally misaligned and they fail the photometry requirements of Federal Motor Vehicle Safety Standard no. 108, lamps, reflective devices, and associated equipment.
Why it matters: The purpose of this standard is to reduce traffic crashes and deaths and injuries by providing adequate illumination of the roadway.
The fix: Sonar will notify owners and offer a full reimbursement for any noncompliant headlamps. The recall began on December 14, 2007. Owners can contact sonar at 866-558-4264.
Exterior lights Equipment recall #07E089000 · 2007 · 238 vehicles
What's wrong: Certain spyder headlamp replacement assemblies sold for use on 2004 through 2007 Ford f150 pickup trucks. During production, the headlamps were internally misaligned and they fail the photometry requirements of Federal Motor Vehicle Safety Standard no. 108, lamps, reflective devices, and associated equipment.
Why it matters: The purpose of this standard is to reduce traffic crashes and deaths and injuries by providing adequate illumination of the roadway.
The fix: Spyder will notify owners and offer a full reimbursement for any noncompliant headlamps. The recall is expected to begin during November 2007. Owners can contact spyder at 866-558-4264.
Exterior lights Equipment recall #09E025000 · 2009 · 42,540 vehicles
What's wrong: Dope, Inc. is recalling 42,540 combination corner and bumper lamp assemblies of various part numbers sold for use as aftermarket equipment for various passenger vehicles. These headlamps fail to conform to the requirements of Federal Motor Vehicle Safety Standard no. 108, "lamps, reflective devices, and associated equipment." these lamps do not contain the required amber side reflectors.
Why it matters: Decreased lighting visibility May result in a vehicle crash.
The fix: Dope, Inc. will notify owners and offer a full refund for the noncompliant combination lamps. The safety recall began on July 28, 2009.
Most-reported problems
Owner complaints filed with NHTSA, by component. One complaint can list several components. 13 mention a fire, 38 injuries and 1 deaths were reported.
What owners describe
- Engine (105): the most common themes are noise or vibration (31), stalls / loses power (25), warning light on (18).
- Transmission & drivetrain (57): the most common themes are hard / delayed shifting (18), noise or vibration (12), stalls / loses power (11).
- Speed control / throttle (54): the most common themes are sudden acceleration (7), stalls / loses power (5).
- Tires (52): the most common themes are tire tread / blowout (49), leaks (9).
The 2007 Ford F-150 has 488 owner complaints, ranking #26 of 37 F-150 model years for complaints (well below the 1025 average). Complaints peaked in 2014 (61 filed that year). The typical problem showed up when the car was about 5 years old, at a median of 57,425 miles. Neighboring years: 2006 (585 complaints, 4 recalls), 2008 (369 complaints, 1 recalls).
Engines & fuel economy (EPA)
| Engine | Transmission | Drive | City | Hwy | Comb. | Fuel |
|---|---|---|---|---|---|---|
| 4.2 L 6-cyl | Automatic 4-spd | Rear-Wheel Drive | 14 | 19 | 16 | Regular |
| 4.2 L 6-cyl | Manual 5-spd | Rear-Wheel Drive | 14 | 19 | 16 | Regular |
| 4.6 L 8-cyl | Automatic 4-spd | Rear-Wheel Drive | 13 | 18 | 15 | Regular |
| 5.4 L 8-cyl | Automatic 4-spd | Rear-Wheel Drive | 13 | 17 | 15 | Regular |
| 4.6 L 8-cyl | Automatic 4-spd | 4-Wheel or All-Wheel Drive | 13 | 17 | 15 | Regular |
| 5.4 L 8-cyl | Automatic 4-spd | Rear-Wheel Drive | 13 | 18 | 15 | Gasoline or E85 |
| 5.4 L 8-cyl | Automatic 4-spd | 4-Wheel or All-Wheel Drive | 12 | 16 | 14 | Regular |
| 5.4 L 8-cyl | Automatic 4-spd | 4-Wheel or All-Wheel Drive | 12 | 16 | 14 | Gasoline or E85 |
Want the full repair deets? Get the factory manual.
Recall and complaint data tells you what goes wrong. A service manual tells you how to fix it: torque specs, wiring diagrams, fluid capacities and step-by-step procedures for the 2007 Ford F-150.
Closest thing to the factory manual for most years. Pay once, keep it.
Most $25–$78, one-timePro-shop repair procedures, wiring diagrams and TSBs for your exact car.
From $19.99/mo · $39.99/yrOEM procedures, specs and recall/TSB info, the same source many shops use.
From $19.99/mo · $59.99/yrStep-by-step photos written from a real teardown. Great for first-timers.
Books ~$30–$40 · AllAccess $34.99/moHeads up: we may earn a commission if you buy through these links, at no extra cost to you. Prices checked 2026-10 and can change. We never host or link to pirated manuals. Disclosure
FAQ
Does the 2007 Ford F-150 have any recalls?
Yes. NHTSA lists 2 vehicle recalls for the 2007 Ford F-150, plus 5 equipment or tire recalls that can apply. Recall repairs are free at any dealer, no matter how old the car is. Check your VIN at nhtsa.gov/recalls.
What are the most common 2007 Ford F-150 problems?
Owners have filed 488 complaints with NHTSA. The most-reported areas are engine (105), transmission & drivetrain (57), speed control / throttle (54).
What gas mileage does the 2007 Ford F-150 get?
EPA ratings run up to 16 mpg combined (4.2 L, Automatic 4-spd), across 8 engine and transmission combos.
Where can I get a 2007 Ford F-150 repair manual?
eManualOnline sells downloadable manuals, Mitchell 1 DIY and ALLDATAdiy sell online access to factory repair data, and Haynes sells printed guides and online access. Pick a download if you want to keep it, or a subscription for wiring diagrams and TSBs.