2000 Mercury Mountaineer: Recalls, Problems & MPG
Here are the deets on the 2000 Mercury Mountaineer: 6 recalls, 123 owner complaints and up to 16 mpg combined.
Recalls
6 vehicle recalls from the manufacturer, plus 2 equipment/tire recalls that can apply. Repairs are free. Check your VIN to see if one is still open on your car.
Electrical Vehicle recall #00V072000 · 2000 · 208,903 vehicles
What's wrong: 0l engines and all-time 4-wheel drive (a4wd) powertrains. The generic electronic module (gem) could experience a condition referred to as "lock-up" in which the gem controlled electronic functions (e.g., front windshield wipers, interior lights, 4x4 system, etc.) could not be turned on or, in some cases if the function is on, could not be turned off.
Why it matters: An inoperative windshield wiper system could affect driver visibility, increasing the risk of a crash.
The fix: Dealers will install a resistor in the gem circuit.
Airbags Vehicle recall #00V179000 · 2000 · 2,300 vehicles
What's wrong: The subject vehicles have a revised level side crash sensor that could deploy the side air bag if the ignition key is in the "run" position and the seatbelt webbing is forcibly extracted from a locked retractor with a jerking motion.
Why it matters: Inadvertent side air bag deployment could cause personal injury to the seat occupant.
The fix: Dealers will replace the side crash sensors with a revised design that will reduce the likelihood of an unexpected side air bag deployment.
Seat belts Vehicle recall #00V228001 · 2000 · 144,435 vehicles
What's wrong: The buckle base of these seat belt assemblies were not properly heat treated and therefore do not pass the load bearing requirement of Federal Motor Vehicle Safety Standard no. 209, "seat belt assemblies."
Why it matters: In the event of a vehicle crash, the occupant May not be properly restrained.
The fix: Dealers will inspect the date code on certain seat belt buckles of your vehicle and replace all seat belt buckles that fall within the suspect date code range. Owner notification began October 26, 2000.
Speed control / throttle Vehicle recall #03V280000 · 2003 · 448,005 vehicles
What's wrong: On certain sport utility vehicles equipped with speed control and 4.0l sohc engines, if the strand cover on the speed control cable becomes flared at the end, the speed control cable May bind when the speed control is activated.
Why it matters: The throttle return spring force May not be sufficient to overcome the binding condition when the speed control is disengaged. Braking function would be maintained though stopping distances May be increased.
The fix: Dealers will inspect the speed control cable and, if necessary, replace it. Owner notification began August 29, 2003. Owners should contact Ford at 1-800-392-3673.
Seats Vehicle recall #03V281000 · 2003 · 1,552,880 vehicles
What's wrong: On certain sport utility vehicles equipped with high back seats, the upper bolt on the driver's side high back seat, that attaches the seat recliner mechanism to the seat back frame, could fracture. If the bolt fractures and does not jam in the seat back frame, the seat back May recline until it makes contact with an object behind the seat, such as the second row seat cushion.
Why it matters: The driver could potentially lose contact with the steering wheel or foot pedals during such an event, increasing the risk of a crash.
The fix: Dealers will replace the driver seat upper bolt with a metal spacer and bolt. In addition, seats with tubular back frames will have the fully threaded lower recliner bolt replaced with a partially threaded bolt. Owner notification began on August 29, 2003. Owners should contact Ford at…
Speed control / throttle Vehicle recall #07V336000 · 2007 · 3,600,000 vehicles
What's wrong: On certain pickup trucks, passenger vehicles, sport utility vehicles, and motor homes chassis, the speed control deactivation switch May, under certain conditions, leak internally and then overheat, smoke, or burn.
Why it matters: This could result in an underhood fire.
The fix: Dealers will install a fused wiring harness. Owners of the passenger cars included in this campaign will be instructed to return their vehicles to their dealers to have the speed control deactivation switch disconnected as an interim repair. As soon as repair parts are available (expected October…
2 aftermarket equipment / tire recalls replacement parts sold to fit this car, not the car itself
Tires Tire recall #00T005000 · 2000 · 14,400,000 vehicles
What's wrong: Tire description: firestone wilderness at, size p235/75r15, produced at the decatur, illinois tire plant and all firestone radial atx and radial atx II tires, size p235/75r15. Operation of these tires at low inflation pressures, high speed, and in hot weather, can contribute to separation of the tire tread.
Why it matters: If the tread separates from the tire, the driver can lose control of the vehicle, possibly resulting in a crash causing injury or death.
The fix: The replacement/reimbursement program for this campaign expired on August 29, 2001. However, customers should contact firestone customer service at 1-800-465-1904 for possible assistance.
Fuel system Equipment recall #06E056000 · 2006 · 58,640 vehicles
What's wrong: Certain aftermarket fuel filters sold under the purolator brand name, p/n f65277, shipped from January 16 through June 2, 2006, for use on the above listed passenger vehicles. Due to incorrect design, the quick connectors May not fully seat with the tube interface, even though the person making the connection May believe that the quick connector is fully attached.
Why it matters: Failure of this connection could lead to fuel spillage and, in the presence of an ignition source, a fire could occur.
The fix: Ufi will notify owners and replace the filters free of charge. The recall began on August 4, 2006.
Most-reported problems
Owner complaints filed with NHTSA, by component. One complaint can list several components. 12 mention a fire, 17 injuries and 0 deaths were reported.
What owners describe
- Speed control / throttle (28): no single recurring theme in the descriptions.
- Tires (22): the most common themes are tire tread / blowout (22).
- Electrical (19): the most common themes are fire / smoke (10), door / lock issues (5), electrical failure (5).
- Transmission & drivetrain (15): the most common themes are hard / delayed shifting (7), noise or vibration (3).
The 2000 Mercury Mountaineer has 123 owner complaints, ranking #7 of 15 Mountaineer model years for complaints (about average; the typical year has 133). Complaints peaked in 2000 (27 filed that year). The typical problem showed up when the car was about 4 years old, at a median of 70,000 miles. Neighboring years: 1999 (151 complaints, 7 recalls), 2001 (22 complaints, 3 recalls).
Engines & fuel economy (EPA)
| Engine | Transmission | Drive | City | Hwy | Comb. | Fuel |
|---|---|---|---|---|---|---|
| 4.0 L 6-cyl | Automatic 5-spd | Rear-Wheel Drive | 14 | 19 | 16 | Regular |
| 4.0 L 6-cyl | Automatic 5-spd | 4-Wheel or All-Wheel Drive | 14 | 19 | 16 | Regular |
| 5.0 L 8-cyl | Automatic 4-spd | Rear-Wheel Drive | 13 | 18 | 15 | Regular |
| 5.0 L 8-cyl | Automatic 4-spd | 4-Wheel or All-Wheel Drive | 13 | 18 | 15 | Regular |
Want the full repair deets? Get the factory manual.
Recall and complaint data tells you what goes wrong. A service manual tells you how to fix it: torque specs, wiring diagrams, fluid capacities and step-by-step procedures for the 2000 Mercury Mountaineer.
Closest thing to the factory manual for most years. Pay once, keep it.
Most $25–$78, one-timePro-shop repair procedures, wiring diagrams and TSBs for your exact car.
From $19.99/mo · $39.99/yrOEM procedures, specs and recall/TSB info, the same source many shops use.
From $19.99/mo · $59.99/yrStep-by-step photos written from a real teardown. Great for first-timers.
Books ~$30–$40 · AllAccess $34.99/moHeads up: we may earn a commission if you buy through these links, at no extra cost to you. Prices checked 2026-10 and can change. We never host or link to pirated manuals. Disclosure
FAQ
Does the 2000 Mercury Mountaineer have any recalls?
Yes. NHTSA lists 6 vehicle recalls for the 2000 Mercury Mountaineer, plus 2 equipment or tire recalls that can apply. Recall repairs are free at any dealer, no matter how old the car is. Check your VIN at nhtsa.gov/recalls.
What are the most common 2000 Mercury Mountaineer problems?
Owners have filed 123 complaints with NHTSA. The most-reported areas are speed control / throttle (28), tires (22), electrical (19).
What gas mileage does the 2000 Mercury Mountaineer get?
EPA ratings run up to 16 mpg combined (4.0 L, Automatic 5-spd), across 4 engine and transmission combos.
Where can I get a 2000 Mercury Mountaineer repair manual?
eManualOnline sells downloadable manuals, Mitchell 1 DIY and ALLDATAdiy sell online access to factory repair data, and Haynes sells printed guides and online access. Pick a download if you want to keep it, or a subscription for wiring diagrams and TSBs.