2002 Gulf Stream Atrium problems & recalls

Problem: Certain motor homes, fifth wheel and travel trailers equipped with a two-door refrigerator, manufactured by the dometic corporation, may have a defect in the boiler tube. pressurized coolant solution could be released into an area where an ignition source (gas flame) is present.

Risk: Release of coolant under certain conditions could ignite and result in a fire.

Fix: Gulf stream will be working with dometic in order to repair these refrigerators (please see 06e076). dometic will repair these refrigerators by installing a secondary burn housing, a thermal fuse, and a melt fuse free of charge. dometic has retained stericycle inc. to manage this campaign. stericycle will assist you in locating dealerships or service centers and will provide assistance with sc

Problem: Gulf stream is recalling certain motorhomes equipped with norcold model 1200lr, 1200lrim, and 1201lrim refrigerators with serial numbers between 1273701 and 1536607, non-consecutively. a fatigue failure in the section of the cooling unit which contains the refrigerant could allow the liquid solution to slowly leak. if a leak occurs and the refrigerator continues to be operated after solution circulation has ceased the heat source could generate very high temperatures. at such high temperatures, the cooling unit could rupture.

Risk: If a leak occurs and the unit continues to operate, hydrogen gas may be expelled and can be ignited, resulting in a fire, possibly causing serious injury or death.

Fix: Gulf stream is working with norcold and the vehicle's refrigerator will be repaired free of charge. please also see norcold's defect notice 09e-027. the safety recall began on october 20, 2009. owners may contact gulf stream at 1-800-289-8787 or norcold's recall center at 1-800-767-9101.

Problem: Gulf stream is recalling certain recreational vehicles and fifth wheel trailers equipped with 1200-series norcold refrigerators. the population of refrigerators being addressed contains either a sensing algorithm or thermal switch to shut off power to the refrigerator when high temperatures are detected in order to prevent a potential fire. the response times of the sensor algorithm and thermal switch devices to stop power are not sufficient.

Risk: The sensing algorithm or thermal switch installed to shut off power to the refrigerator when high temperatures are detected due to a possible hydrogen gas leak may not shut off in sufficient time to prevent a fire.

Fix: Gulf stream is working with norcold to identify and notify any affected owners. owners will be instructed to contact norcold dealers to receive the remedy free of charge. please see norcold's defect report 10e-049 for additional information. the recall began on march 23, 2011. owners may contact norcold at 1-800-767-9101 or gulf stream at 1-574-773-7761.