2001 Winnebago Brave problems & recalls

Problem: Vehicle description: motor homes. the copper line supplying liquid propane gas (lpg) to the furnace may have been improperly clamped, which could cause the line to come in contact with a metal flange.

Risk: If this happens, the copper line could be damaged and could develop a leak which has the potential to ignite.

Fix: Dealers will re-route the lpg line. owner notification began april 12, 2001. owners who take their vehicles to an authorized dealer on an agreed upon service date and do not receive the free remedy within a reasonable time should contact winnebago at 1-641-585-6939.

Problem: Vehicle description: class a motor homes equipped with safety belt assemblies built by am-safe. on some seat belts, the buckle and connector may unlatch during a collision.

Risk: Serious injury or death could occur if the vehicle occupant is not properly restrained.

Fix: Dealers will inspect the lap belts and, if necessary, replace it with a new belt assembly. owner notification began may 25, 2001. owners who take their vehicles to an authorized dealer on an agreed upon service date and do not receive the free remedy within a reasonable time should contact am-safe at 1-219-266-8330 or winnebago at 1-641-585-6939.

Problem: Vehicle description: motor homes built on a ford chassis. these vehicles may have the incorrect liquid propane (lp) gas tank bracket. depending on how the tank was installed, there may not be adequate clearance between the tank and a bolt head on the suspension. without clearance, the tank could be damaged.

Risk: Over time, could develop a leak which has the potential to ignite, resulting in bodily injury and/or property damage.

Fix: Dealers will reposition the lp gas tank. owner notification began july 19, 2001. owners who take their vehicles to an authorized dealer on an agreed upon service date and do not receive the free remedy within a reasonable time should contact winnebago at 1-641-585-6939.

Problem: Certain motor home chassis fail to comply with the requirements of federal motor vehicle safety standard no. 105,"hydraulic and electric brake systems." the brake system warning indicator may not function as required by the standard.

Risk: In some of the affected vehicles, the brake system warning indicator will not illuminate when the ignition is in the start position or for a low brake fluid condition, if the body builder relied solely upon ford's ivm compliance statement for the system warning indicator.

Fix: Dealers will repair these vehicles. owner notification began april 25, 2003. owners who take their vehicles to an authorized dealer on an agreed upon service date and do not receive the free remedy within a reasonable time should contact winnebago at 1-641-585-3535.

Problem: On certain motor homes equipped with samsung microwave ovens, these units were produced with a defective panel. an electrical short can occur between circuit patterns on the membrane panel, especially overlapped by a "jumper" or jump wire. this may cause the oven to activate without pressing any key pads.

Risk: An electrical short can occur causing the oven to activate without pressing any key pads. this could result in excessive heat, smoke, or possibly a fire.

Fix: Samsung will notify customers and repair the panel free of charge. in the meantime, consumers should unplug their microwave, if possible. if the consumer is unable to unplug the microwave, they should leave the door ajar until the panel is replaced. consumers should never use the microwave oven for storage or leave any towels, paper, cloth or other products in the microwave after use. owners w

Problem: Winnebago is recalling my 1999-2002 ultimate advantage, ultimate freedom, my 1999-2001 chieftain, my 2000-2001 brave, my 2001 journey my 2000 minnie winnie, my 2000-2002 itasca horizon, my 1999 suncruiser, my 2001 sunflyer, and my 2000 sunrise motor homes equipped with norcold refrigerators. a fatigue failure in the section of the cooling unit which contains the refrigerant could allow the liquid solution to slowly leak.

Risk: Extended operation of a leaking cooling unit could lead to a fire from gas which might escape.

Fix: Winnebago is working with norcold to repair these refrigerators. norcold will provide thermal switch kits to owners along with the necessary forms and instructions. the manufacturer has not yet provided an owner notification schedule for this campaign. owners may contact norcold at 1-800-767-9101 or winnebago at 1-641-585-3535.

Problem: Winnebago is recalling certain recreational vehicles equipped with 1200-series norcold refrigerators. the population of refrigerators being addressed contains either a sensing algorithm or thermal switch to shut off power to the refrigerator when high temperatures are detected in order to prevent a potential fire. the response times of the sensor algorithm and thermal switch devices to stop power are not sufficient.

Risk: The sensing algorithm or thermal switch installed to shut off power to the refrigerator when high temperatures are detected due to a possible hydrogen gas leak may not shut off in sufficient time to prevent a fire.

Fix: Winnebago is working with norcold to identify and notify any affected owners. owners will be instructed to contact norcold dealers to receive the remedy free of charge. please see norcold's defect report 10e-049 for additional information. the recall began during december 2010. owners may contact norcold at 1-800-767-9101 or winnebago at 1-641-585-3535.